Use and Care Manual

ManualsBrandsStark ManualsOutdoor Power Equipment6.5 HP Gas Plate Compactor Vibratory Asphalt/Soil with Water Tank

Owner’s Manual

PLATE COMPACTOR

61006/61007

Questions? Problems? Please call our customer support:

(909) 628 4900 Mon-Fri 9am to 3pm PST

WARNING

To reduce the risk of injury，all operators and maintenance personnel

must read and understand these instructions before operating, changing

accessories, or performing maintenance on this power equipment.

All possible situations cannot be covered in these instructions.

Care must be exercised by everyone using, Maintaining or working near

this equipment.

Summary of content (10 pages)

PAGE 1
Owner’s Manual PLATE COMPACTOR 61006/61007 Questions? Problems? Please call our customer support: (909) 628 4900 Mon-Fri 9am to 3pm PST WARNING To reduce the risk of injury，all operators and maintenance personnel must read and understand these instructions before operating, changing accessories, or performing maintenance on this power equipment. All possible situations cannot be covered in these instructions. Care must be exercised by everyone using, Maintaining or working near this equipment.
PAGE 2
CONTENTS without adequate instruction.
PAGE 3
DO NOT refuel the motor while it is in operation or hot.
PAGE 4
Petrol Engine 1．Open the fuel tap by moving the fuel ON/OFF lever fully to the right． 2．If starting the engine from cold, set the choke ON by moving the choke lever fully to the left ．If restarting a warm engine,the choke is usually not required．However,if the engine has cooled to a degree．partial choke may be required． 3．Turn the engine ON/OFF switch clockwise to the "1" position． 4．Set the throttle to the idle position by moving the throttle lever fully to the right．Do not start the engine on full throttl
PAGE 5
Inspection and other services should always be carried out on hard and level ground with the engine Check for loose screws including tightness．See Table 3 below(tightening torque),for re-tightening． shut down． TABLE 3.
PAGE 6
1007 caught between the V-belt and the clutch．Always use safety gloves． Petrol, Honda GXl60 Governed speed ● Checking and Replacing the V-belt and Clutch After 200 hours of operation, remove the upper belt cover to check the V-belt tension(Figure 2)．Tension is proper if the belt bends about 10mm when depressed strongly with finger between shafts．Loose or worn V-belts reduces power transmission efficiency, causing weak compaction and reduces the life of the belt itself． 4.0 kW output 3.
PAGE 7
Working Size(L×W×H)： TRANSPORTATION 69×50×105cm 1.Always shut off engine when transporting machine． 2.Make sure lifting device has enough capacity to hold machine(see identification plate on machine for weight)． 3.Use central lifting point(a)when lifting machine． 4.
PAGE 8
ENGINE TROUBLESHOOTING SYMPTOM POSSIBLE CAUSE Short 0circuit due to deficient spark plug insulation? Check gap．insulation or replace spark plug． Clean or replace spark plug． Check spark plug insulation, replace if worn． Improper spark plug gap? ON/OFF switch is shorted? Ignition coil defective? Improper spark gap，points dirty? Set to proper gap． Check switch wiring,replace switch． Replace ignition coil． Set correct spark gap and clean points． Spark plug bridging? Difficult to start, "fuel is available
PAGE 9
61006/61007 SPARE PARTS LIST ITEM NO. DESCRIPTION QUANTITY ITEM NO. DESCRIPTION SPEC.
PAGE 10
-9-