Replacement Part List
5
OPERATION
1. Turn the STOP SWITCH clock-wise to the position “1”(ON).
GASOLINE ENGINE STARTING
2. Open the fuel cock.
3. Set the speed control lever 1/3 to 1/2 of the way towards the high
speed position.
4.Close the choke lever. If the engine is warm or the ambient temperature
is high, open the choke lever half-way, or keep it fully open. If the engine
is cold or the ambient temperature is low, close the choke lever fully.
5. Pull the starter handle slowly until resistance is felt. This is the
compression point. Return the handle to its original position and pull
swiftly. Do not pull out the rope all the way. After starting the engine allow
the starter handle to return to its original position while still holding the
handle.
Turn the throttle lever to START position(open by about 30 degrees See
Fig. 5D
DIESEL ENGINE
THROTTLE LEVER
OPEN 30
DEGREES
FIG. 5D
Operate Starter
In case of recoil starter. By pulling the starter knob slowly, you will reach
such point where resistance become strong(compression point). by
pulling it further, you will Find a point where resistance is reduced. Return
the knob but slowly return it original.
STOP SWITCH
FUEL COCK
CAUTION: DO NOT pull the rope all the way and DO NOT take your
hand off the pulled knob but slowly return it to the original position.
After starting up the engine, be sure to perform a warm up the engine,
be sure to perform a warm up run for 2 to 3 minutes. This should be
performed without fail, particularly during winter season.
Operation
As the engine warms up, gradually move the choke lever to the OPEN
position. Move the speed control lever from the LOW to the HIGH position.
When the engine speed reaches approximately 2,300-2,600 RPM, the
centrifugal clutch engages. If the engine speed increased very slowly, it
is possible that the clutch can slip. Do not operate the speed control lever
slowly.
Oil Alert System
The Oil Alert System is designed to prevent engine damage caused by
an insufcient amount of oil in the crankcase. Before the oil level in the
crankcase can fall below a safe limit the Oil Alert System will automatically
stop the engine(the engine switch will remain in the ON position).
NOTE: If the engine stops and will not restart, check the engine oil level.