Installation Instructions and Manual

8
WARNING!
The shipping weight of your American
Muscle Grill is at least 250 pounds. Larger
units may weigh over 400 pounds. Use two
or more people to move or install this unit.
Failure to follow this instruction can result
in back or other personal injuries.
Wear your protective gloves while using the
grill or any time you come into contact with
the grill while it is hot. Never use the liing
tool without your protective grilling gloves.
WARNING!
1. Fully welded stainless steel grill cart
2. 100 lb. Commercial quality rotisserie kit
3. Professional plug and play sear burner
4. Side power burner
5. Masonry stainless steel sealed fuel storage
bin/access door combo
6. Sealed stainless steel masonry double
vertical drawer kit
7. Masonry stainless steel LP tank/dual trash
receptacle pullout
8. Masonry stainless steel double access door
9. Large stainless steel single access door
10. Propane (LP) conversion kit
11. Natural gas (NG) conversion kit
AVAILABLE OPTIONS & ACCESSORIES
IMPORTANT INSTALLATION WARNINGS
• Please read all instructions before
installing or operating your gas grill
to prevent injury and appliance
damage.
• Never test the grill for gas leaks using
a lighted match or any other open
flame; see “Leak Testing” procedures
using soap/water solutions included
in following pages of this manual.
• The use of accessories, regulators,
or components not recommended
by the appliance manufacturer may
cause injuries and will void warranty.
• Be sure that the gas supplied to
the grill conforms to the model
you purchased. A Natural Gas grill
requires natural gas to operate; an
LP grill requires liquid propane gas to
operate. Check the rating label on the
le hand side of the unit to be certain
of the gas type intended for this grill.
• Your AMG grill is equipped with
a convertible gas regulator that is
set at our factory for the type of
gas indicated on the rating plate.
Never connect the appliance to an
unregulated gas supply line. Grills
operated without a regulator are
unsafe and will not be serviced until
installed properly and safely. Unsafe
operation without a gas regulator will
void warranty of the grill.
• Grills operated with NG (natural gas)
must be installed with the regulator
supplied with the unit and set to 4.0”
water column pressure.
• Grills operated with LP (liquid
propane) gas must be installed with
the regulator supplied with the unit
and set to 11” water column pressure.
• The gas valves used in the grills are
preset at the factor for Natural Gas
or Liquid Propane operation. Please
contact your dealer and use a licensed
contractor or installer to convert your
grill to a different gas type.
• Never locate the grill under
combustible construction.
UNPACKING THE CARTON
1. 1. Cut the strapping that secures the grill to
the pallet.
2. Remove the staples on the lower sides
of the carton. Note: It is not necessary
to remove the staples at the top of the
carton.
3. Slide the carton over the top of the grill
and set aside.
4. Remove all LOOSE interior packaging and
paperwork from the grill and set safely
aside. Be careful to keep all important
documentation for future reference.
5. Open the hood and remove all
accessories and packaging from inside
the grill.
6. Carefully remove all the screws securing
LIGHTING YOUR GRILL