Installation Instructions and Manual

11
OPERATION
1. Turn control knobs and cylinder valve to the
OFF position.
2. Unscrew valve.
3. Remove cylinder and have it filled at your
local qualified propane dealer.
4. Once filled, carefully connect the valve and
make sure it is secure and not leaking.
5. With the grill control knobs in the OFF
position, turn on the cylinder valve.
6. If you smell gas or hear a hiss of gas
escaping from the tank, turn the cylinder
valve OFF, get away from the tank and do
not aempt to correct the problem yourself.
7. Call the Fire Department immediately.
8. If your grill has no leak at the cylinder, then
re-check for loose connections and retest
for leaks using the method detailed in the
following pages with soapy solution.
REFILLING PROPANE
(
LP
)
TANKS
NOTE!
Transport only one cylinder at a time.
Ensure the cylinder is secured in an upright
position with the control valve turned off
and the dust cap in place. Store cylinders
outdoors and out of reach of children. Do
not store cylinders in a building, garage, or
any other enclosed area.
• All purging and refilling of LP gas
cylinders must be performed by
qualified personnel in the LP gas
industry. Never store a spare LP gas
cylinder under or near this appliance.
• Never fill the LP gas cylinder beyond
80 percent full. Failure to follow these
instructions may result in explosion,
personal injury or death.
• Remember-before exchanging an
empty bole for a new one, make
sure all control valves are in the “OFF”
position.
• Never use dented, rusty or damaged
propane cylinders. Never store
additional or empty propane cylinders
in the grill cabinet or in the vicinity of
this or any other appliance. Do not
store propane cylinders indoors or on
their sides
• Do not subject your LP gas cylinder to
excessive heat, and always store the
cylinder in an upright position. Never
store your LP cylinders indoors.
• Make sure that when aaching
components, all connections are
secured and fully tightened to prevent
leakage.
• If one is not already available, it is
recommended that an ON-OFF
shutoff valve be installed at the gas
supply source, and that the gas supply
be turned off when either Natural Gas
or LP Gas grills are not in use.
LP GAS CYLINDERS. FILLING,
REFILLING AND USE
WARNING!
around the grill, in the cart, or in the
masonry enclosure.
• Never move the grill when hot. When in
use, portions of the grill are hot enough
to cause severe burns.
• Gas grills are not designed or certified
for, and are not to be installed in or on
recreational vehicles, portable trailers,
boats or any other moving installation.
• Always have an ABC Fire Extinguisher
accessible — never aempt to extinguish
a grease fire with water or other liquids.
• Store your grill in a well-ventilated area.
If stored indoors, detach and leave L.P.
Cylinder outdoors in a well ventilated
area away from heat and away from
where children may tamper with it.
• Keep any electrical supply cord and the
fuel supply hose away from any heated
surfaces. Electrical cords should be
placed away from walkways to avoid
tripping hazard.
• Do not store spare LP gas cylinders
under or near this appliance.
• Be sure that you know where your gas
supply shut-off is located. All gas lines
must have a shutoff that is readily and
easily accessible.
• Inspect the LP gas supply hose prior to
each use of the grill. If there is evidence
of excessive abrasion or wear, or the hose
is cut, it must be replaced before using
the grill.
• Never remove the grounding prong
from the plug or use this product with an
ungrounded, 2-prong adapter.