Installation Instructions and Manual

3 4
SAFETY AND INSTALLATION WARNINGS
• Please read all instructions before installation or operating your gas grill to prevent injury and appliance damage
• All gas grills will get hot during use. Use extreme caution when operating the grill
• Do not touch hot surfaces. Always use the handle to open or close the grill
• Never use dented, rusty or damaged propane cylinders. Never store additional or empty propane cylinders in the grill
cabinet or in the vicinity of this or any other appliance
• Close supervision is necessary when this or any appliance is used near children. Keep children away from the grill during
operation and until the grill has cooled off
• Children should never be left alone or unattended in an area where a grill is located. Place your grill well away from areas
where children play. Do not store items that may interest children in or around the grill, in the cart, or in the masonry enclosure
• Never move the grill when hot. When in use, portions of the grill are hot enough to cause severe burns.
• Always maintain the required clearances from combustibles as detailed. The grill is designed for outdoor use only. Never
use in a garage, building, shed, breezeway, or other enclosed area. Do not use this grill under any unprotected overhead
combustible construction
• Gas grills are not designed or certified for and are not to be installed in or on recreational vehicles, portable trailers, boats
or any other moving installation
• Always have an ABC Fire Extinguisher accessible — never attempt to extinguish a grease fire with water or other liquids.
• Storing your grill: Store your grill in a well-ventilated area. If stored indoors, detach and leave L.P. cylinder outdoors in a
well-ventilated area away from heat and away from where children may tamper with it
• Keep any electrical supply cord and the fuel supply hose away from any heated surfaces. Electrical cords should be placed
away from walkways to avoid tripping hazard
• Do not repair or replace any part of the grill unless specifically recommended in this manual. Other service should be
performed by a qualified technician
• If the grill is installed by a professional installer or technician, be sure that he/she shows you where your gas supply shut-
off is located. All gas lines must have a shut-off that is readily and easily accessible. If you smell gas, check for gas leaks
immediately. Check only with a soap and water solution. Never check for gas leaks with an open flame.
• Do not twist the gas supply hose
• Inspect the L.P. gas supply hose prior to each use of the grill. If there is evidence of excessive abrasion or wear, or the hose
is cut, it must be replaced before using the grill
• The use of accessories, regulators, or components not recommend by the appliance manufacturer may cause injuries and
will void warranty
• Never light the grill with the hood closed and be certain the burners are positioned and seated over the gas valves and on
the burner support
• Never lean over the cooking surface when lighting or operating the grill
• Use barbecue tools with wood handles and insulated oven mitts when operating the grill
• Be sure the gas supplied to the grill conforms to the model you purchased. A natural gas grill requires natural gas to operate;
a liquid propane grill requires liquid propane to operate
• Never connect the appliance to an unregulated gas supply line. Grills operated without a regulator are unsafe and will not
be serviced until installed properly and safely. Unsafe operation without a gas regulator will void the warranty
• Grills operating with natural gas must be installed with the NG regulator supplied with the unit and set to 4.0” of water
column pressure
• Grills operating with liquid propane must be installed with an LP regulator and set to 11” of water column pressure
WARNING!
READ THIS MANUAL CAREFULLY
and completely before using your grill to reduce the risk of:
1. Fire
2. Burn hazard, personal injury or property damage
3. Improper installation or servicing
4. Electric Shock
WARNING!
CALIFORNIA PROPOSITION 65
1. This product can expose you to chemicals including
polycyclic aromatic hydrocarbons which is known
to the State of California to cause cancer and birth
defects or other reproductive harm.
2. California law requires businesses to warn customers
of potential exposure to such substances. To minimize
exposure to the substances, always operate this unit
according to the use and care instructions found in this
manual. Be certain to provide adequate ventilation
when cooking.
WARNING!
EXPLOSION HAZARD:
• DO NOT use the grill as a storage area for flammable
materials. Keep area clear and free from combustible
materials, gasoline, and other flammable vapors and
liquids. Failure to
do so can result in death, explosion,
or fire
• An LP cylinder not connected for use shall not be stored
in the vicinity of this or any other appliance
WARNING!
• The outdoor cooking gas appliance and its dedicated
shutoff valve must be disconnected from the gas supply
piping system during pressure testing of that system at
test pressures in excess of .5 psi (3.5kPa).
• The outdoor cooking gas appliance must be isolated
from the gas supply piping system by closing its
dedicated manual shutoff valve during any pressure
testing of the gas supply piping system at test pressures
equal to or less than .5 psi (3.5kPa).
WARNING!
THIS PRODUCT IS DESIGNED FOR OUTDOOR USE
ONLY
Improper installation, adjustment, alteration, service or
maintenance can cause property damage, injury or death.
Read this manual thoroughly before installation, use, or
servicing of this product.
WARNING!
CODE AND SUPPLY REQUIREMENTS:
This grill must be installed in accordance with local codes
and ordinances, or, in the absence of local codes, with
the latest National Fuel Gas Code (ANSI Z223.1/NFPA
54), or Natural Gas and Propane Storage and Handling
Installation Code (CSA-B149.1)
WARNING!
IF YOU SMELL GAS:
Improper installation, adjustment, alteration, service or
maintenance can cause property damage, injury or death.
Read this manual thoroughly before installation, use, or
servicing of this product.
DANGER!
IF YOU SMELL GAS:
• Shut off all gas supply lines to the grill
• Extinguish any open flames
• Carefully open the lid. Remember, it may be extremely
hot!
• If odor continues, keep everyone away from the grill
and immediately call your gas supplier or your fire
department
DANGER!
STATE OF
MASSACHUSETTS
• Massachusetts requires all gas be installed using
a plumber or gas fitter carrying the appropriate
Massachusetts license.
• All permanently-installed natural gas or propane
installations require a "T" handle type manual gas valve
be installed in the gas supply line to this appliance.
• This does not apply to portable propane installations
using a 20 pound cylinder.
WARNING!