&y Swan wwuw.swanstone.
Safety Guidelines The Swan Assurance — if our product is properly installed and maintained, as stated in these instructions, it will nat leak. Remember = Safety First I IMPORTANT NOTICE The Swan Corporation, the makers of the Swan products, cannot anticipate every possible circumstance that might involve a potential hazard during the installation of our product(s).
Safety Guidelines General Information Personal Protection Be sure to use all personal protective equipment, such as sturdy work boots, preferably with steel oles, gloves, and hard hat, if necessary, to ensure your own safely. To prevent possible damage to your hearing, always wear ear protection, such as earmuffs or earplugs, when working around power tools. Cutting Hazard The installation of the Swan stone product may require using power teals.
General Information Installation Procedure Kit Contents Confirm that all parts of this kit have been included before beginning installation, RS-2215 Recessed Shampoo Half ‘1 — Recessed Shampoo Shelf AS-1075 Recessed Accessory Shelf 1 — Recessed Accessory Shelf For best results, use 100% clear silicone sealant for bonding this product to a properly constructed and prepared sub wall, You will need one tube of 100% clear silicone sealant {tube sized o fit a standard caulking gun) for every 1440 square inches o
Safety Guidelines 2. Mark the wall panel with the stud locations, as shown. A standard height for the recessed shelf would be 43" from the shower floor to the bottom of the opening, For R-2215, mark the measurements, as shown, for the cut out onto the wall panel. Try to center the opening in the stud pocket. The wall stud opening shown is 16" on center, which creates a opening. 4. For AS-1075, mark the measurements, as shown, for the cut out onto the wall panel.
Installation Procedure 8. Remove the tape, and clean the panel surface with 1. Secure the shelf in place with masking ape, as shown. denatured alcohol or another non-ill based solvent. Allow 24 hours for the silicone to dry. AS-1075 {e@ The installation is now complete. DO NOT discard these installation instructions, PLEASE LEAVE THEM WITH THE IMPORTANT NOTICE HOMEOWNER. Do not use oil-based cleaners, such as mineral spirals, o clean the panels.
Maintenance & Cleaning Warranty Care and Cleaning The Swan stone products are stain and abrasion resistant; however, the finish requires reasonable care. IMPORTANT NOTICE Because cleaning products change over time, always check the manufacturer's instructions to make sure it is compatible with plastic. DO NOT use a cleaner if the label indicates it should nat be used on plastics.
Save these Installation Instructions for future reference. They provide important information on cleaning, maintenance, and surface repair of the Swan stone Wall Systems and Canals. &Y Swan www.swanstone.