® TWIN EAGLES, INC. Defining the Art of Outdoor Cooking TWIN EAGLES ALL WEATHER ELECTRIC RADIANT HEATER OWNER’S MANUAL MODEL TEEH-1512 TEEH-2524 TEEH-3524 NEED ASSISTANCE? PLEASE CALL: (562) 802-3488 This heater must be permanently installed and hard wired by a licensed contractor. TWIN EAGLES, INC. 13231 East 166th St. Cerritos, CA 90703 1(562) 802-3488 www.twineaglesbbq.com P/N 18584 A (10/06) Made in U.S.A.
TABLE OF CONTENTS – ELECTRIC HEATER IMPORTANT INFORMATION Assembly Instructions………………………………………………………………………...……2 Mounting Suggested Locations.…………………………………………………………………....3 Mounting Instructions…………………………………………………………………………...…4 Wiring Instructions………..……………………………………………………………………….5-6 NOTE: DO NOT mount the heater on a vertical axis. Such installation will reduce the life of the element and will automatically VOID the product’s warranty.
ASSEMBLY INSTRUCTIONS – ELECTRIC HEATER NOTE: a) The heater must be permanently installed and hard wired by a licensed contractor. b) Twin Eagles electric heater is shipped with the heating element uninstalled to prevent it from breaking from any possible shipping impact. c) Assembly procedure must be performed with no electrical power to the unit. 1) When you open the box, all components should be organized as seen on the picture.
MOUNTING SUGGESTED LOCATIONS – ELECTRIC HEATER Unless heaters are installed over 12 ft. high, it is generally recommended that radiant heaters be mounted on an angle to assure that radiant warmth is distributed from the sides rather than straight down on the heads and shoulders of people being warmed. When outdoors, hang heaters under protective roof or weather cover whenever possible. Even though heater is all-weather construction, it will last longer and look better if protected from rain and dew.
MOUNTING INSTRUCTIONS – ELECTRIC HEATER The following information is provided to direct you on how and where to mount TWIN EAGLES ELECTRIC HEATERS. Our heaters may be the most economical to install, depending on the location of electrical power adequate to operate the heater(s) properly. All models come with standard wall-ceiling swivel mounting brackets for each side…which MUST be used. All hardware is included; reference pictures below to Swivel Point Inside View install the brackets to the heater unit.
WIRING INSTRUCTIONS – ELECTRIC HEATER Twin Eagles electric heaters are one of the most economical radiant heaters to buy and can be some of the least costly to operate. Twin Eagles electric heaters convert 90% of its input power into radiant heat and only have an electrical consumption of 1.5kW to 3.5kW per hour (varies per heater size). NOTE: a) This heater must be permanently installed and hard wired by a licensed contractor.
CONTINUATION FROM PREVIOUS PAGE TYPICAL 120V WIRING (not included) FOR 120V SWITCH TYPICAL 240V WIRING (not included) FOR TWO POLE SWITCH Heater Heater WIRING FOR OPTIONAL (not included) 120V or 240V INCREMENTAL CONTROL Optional Pilot Light (120V) Optional Pilot Light (240V) 120V 240V TEIC-4094 INF-20 240Volts TEIC-4092 INF-10 120Volts Top Top 1800 Watts at 120 Volt Maximum Load Rear view of controller for Max. 15 Amp load ONLY.
REPLACEMENT PARTS LIST – ELECTRIC HEATER Item Part Number Number Part Description Qty 1 2a 2b 2c 3a 3b 3c 4 5 6a 6b 6c 6d 6e 7 16210 16211 16212 16213 16214 16215 16216 16217 16218 TERE-1065 TERE-2010 TERE-2053 TERE-2020 TERE-3528 13112 End Reflector Set (2 pcs) 1500 Body Reflector 2500 Body Reflector 3500 Body Reflector set (2 pcs) 1500 safety grill 2500 safety grill 3500 safety grill Lead wire set (2 pcs) (NOT SHOWN) Mounting bracket set (2 pcs) (NOT SHOWN) 1500 W 120 V Replacement elements (for TE
TROUBLESHOOTING GUIDE – ELECTRIC HEATER PROBLEM 1. Heater is warm but not hot. Element does not glow orange. 2. Element does not come on at all. WHAT TO DO 1. Check for low voltage 2. If voltage is 208 volts, use element rated for 208 volts instead of 240 volts. 1. Check if there is power to the unit. 2. Check for proper connection of line 1 and line 2 on the controller. 3. Element glows orange but the heater is not hot enough 1. Check recommended mounting height against model. 4.
TWIN EAGLES ELECTRIC HEATER Limited Product Warranty Model: ______________________________ Serial No: ___________________________ Date of Purchase: ______________________ Selling Dealer: _______________________ Thank you very much for purchasing a high quality Electric Heater from Twin Eagles, Inc. We have designed this heater to provide you and your family with many years of great comfort heating experiences.
Place Postage Here Cut Here Customer Service ATTN: Warranty Department 13231 East 166th Street Cerritos, CA 90703 Fax no. (562) 802-3391 Fold Here Warranty Registration Customer Name Model # Address Serial # City Date Purchased Zip Dealer’s Name Phone # Dealer’s Address e-mail: This Warranty Registration card must be returned within thirty days of purchased to properly activate your warranty. This information is for our internal use only. A P/N 18584 A (10/06) Made in U.S.A.