SDS

ManualsBrandsUSG Ceilings ManualsCeilingsUSG™ Radar™ ClimaPlus™ 2' x 4' White Acoustical Drop Ceiling Tile

SAFETY DATA SHEET

1. Identification

Product identifier USG® Radar™ Basic Acoustical Ceiling Panels

Other means of identification

SDS number

41999270001

Additional Products

Radar™, Radar™ High Durability, Radar™ Illusion, Adobe™, Fifth Avenue™, Fissured™ Basic,

Majestic, Moonscape™, Plateau™, Sierra™, Stonehurst™ Acoustical Ceiling Panels

Synonyms

Ceiling Tiles, Water Felted Mineral Fiber Ceiling Panels/Tiles

Recommended use

Interior use.

Recommended restrictions

Use in accordance with manufacturer's recommendations.

Manufacturer/Importer/Supplier/Distributor information

Company name

USG Interiors, LLC

Address

550 West Adams Street

Chicago, Illinois 60661-3637

Telephone

1-800-874-4968

Website

www.usg.com

Emergency phone number

1-800-507-8899

2. Hazard(s) identification

Not classified.

Physical hazards

Category 1ACarcinogenicity

Health hazards

Category 2 (Lung)Specific target organ toxicity, repeated

exposure

Not classified.

OSHA defined hazards

Label elements

Signal word

Danger

Hazard statement

May cause cancer. May cause damage to organs (Lung) through prolonged or repeated exposure

by inhalation.

Precautionary statement

Prevention

Obtain special instructions before use. Do not handle until all safety precautions have been read

and understood. Do not breathe dust. Wear protective gloves/protective clothing/eye

protection/face protection.

Response

If exposed or concerned: Get medical advice/attention.

Storage

Store locked up.

Disposal

Dispose of in accordance with local, state, and federal regulations.

Hazard(s) not otherwise

classified (HNOC)

None known.

3. Composition/information on ingredients

Mixtures

93763-70-3 < 55Perlite

CAS number %Chemical name

9004-34-6 < 20Cellulose

N/A < 15Slag wool fiber

USG® Radar™ Basic Acoustical Ceiling Panels SDS US

918325 Version #: 01 Revision date: - Issue date: 19-December-2014

1 / 8

Summary of content (8 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier USG® Radar™ Basic Acoustical Ceiling Panels Other means of identification SDS number 41999270001 Additional Products Radar™, Radar™ High Durability, Radar™ Illusion, Adobe™, Fifth Avenue™, Fissured™ Basic, Majestic, Moonscape™, Plateau™, Sierra™, Stonehurst™ Acoustical Ceiling Panels Synonyms Ceiling Tiles, Water Felted Mineral Fiber Ceiling Panels/Tiles Recommended use Interior use.
PAGE 2
Kaolin 1332-58-7 < 10 Limestone 1317-65-3 < 10 Starch 9005-25-8 < 10 Calcium carbonate 471-34-1 <2 CAS number % 14808-60-7 ≤2 Impurities Chemical name Crystalline silica (Quartz) Composition comments All concentrations are in percent by weight unless ingredient is a gas. Raw materials in this product contain respirable crystalline silica as an impurity. The weight percent of respirable crystalline silica found in this product is ≤ 2%.
PAGE 3
Methods and materials for containment and cleaning up No specific clean-up procedure noted. For waste disposal, see Section 13 of the SDS. Environmental precautions Avoid discharge to drains, sewers, and other water systems. 7. Handling and storage Precautions for safe handling Conditions for safe storage, including any incompatibilities Use work methods which minimize dust production. Avoid inhalation of dust and contact with skin and eyes. Wear appropriate personal protective equipment.
PAGE 4
US. NIOSH: Pocket Guide to Chemical Hazards Value Form 10 mg/m3 5 mg/m3 10 mg/m3 5 mg/m3 10 mg/m3 3 fibers/cm3 Type 5 mg/m3 5 mg/m3 10 mg/m3 Value Total Respirable. Total Respirable. Total Fiber, respirable (diameter ≤ 3.5 µm and length ≥ 10 µm) Fiber, total Respirable. Total Form TWA 0.05 mg/m3 Respirable dust.
PAGE 5
Upper/lower flammability or explosive limits Not applicable. Flammability limit - lower (%) Flammability limit - upper (%) Not applicable. Explosive limit - lower (%) Not applicable. Explosive limit - upper (%) Not applicable. Vapor pressure Not applicable. Vapor density Not applicable. Relative density 0.2 - 0.22 (H20=1) Solubility(ies) Solubility (water) Very low solubility in water. Partition coefficient (n-octanol/water) Not applicable. Auto-ignition temperature Not applicable.
PAGE 6
NTP Report on Carcinogens Crystalline silica (Quartz) (CAS 14808-60-7) Known To Be Human Carcinogen. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed. No data available, but none expected. Reproductive toxicity Specific target organ toxicity single exposure No data available, but none expected. Specific target organ toxicity repeated exposure May damage lung tissue through repeated and prolonged exposure to high levels of respirable crystalline silica particles.
PAGE 7
Superfund Amendments and Reauthorization Act of 1986 (SARA) Immediate Hazard - No Hazard categories Delayed Hazard - Yes Fire Hazard - No Pressure Hazard - No Reactivity Hazard - No SARA 302 Extremely hazardous substance Not listed. SARA 311/312 Hazardous chemical Yes SARA 313 (TRI reporting) Not regulated. Other federal regulations Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Not regulated. Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.
PAGE 8
Version # Further information 01 Crystalline silica: Raw materials in this product may contain respirable crystalline silica as an impurity. Exposures to respirable crystalline silica are not expected during the normal use of this product. However, actual levels must be determined by workplace hygiene testing.