Operator`s manual

--- 7 7 ---
H. Periodic maintenance
H4.6. Change engine oil and engine
oilfilter (16)
In extremely dusty conditions or when using over 5 %
Biodiesel fuel, the oil and filters should be changed every
250 hours.
If the amount of operating hours is low, the oil and filters
should be changed at least once per year.
H 4.6.1. Draining
65--- 68
Remove the drain plug and allow the oil to run out into a
suitable container. Drain the oil while the engine is warm
(makes draining quicker particularly in cold weather).
Clean the plug and replace it.
H 4.6.2. Changing oil filter
AH23
2
3
1
--- R e m o ve th e o i l f il t e r ( 1) by unscrewing it
--- Wipe off the oil which has run out on the chassis
--- Oil the new gasket
--- Tighten the new filter by hand (not too hard).
H 4.6.3. Crankcase ventilation
When changing the oil always check that the ventilation
pipe is clean and not blocked.
H 4.6.4. Filling
Oil quality is to be in accordance with the table on
page 64.
Fill up with new oil to the prescribed level (upper mark on
dipstick 3) through the filler opening (2).
Oil volume incl. filter
---A75n, A75L---A95L 7l..............................
---A85n, A95n 9l....................................
Filter capacity 0.5 I.
The distance between max and min marks on the dipstick
corresponds to 1.5 liters of oil.
Then start the engine in the normal way. Allow the engine
to idle for a little while and check the oil level again.
H4.7. Check free t ravel of brake pe-
dals (17)
A3565--- 102,1
60 mm
Thefreetravelshouldbe60 mm (2.4 in) when the pedals
are connected together. Adjust the free travel if necessary
(see under ” Checks and adjustments” on page 94).
H 4.7.1. Adjusting parking brake
65--- 73
The parking brake acts on the foot brake mechanism
mechanically by means of a rod.
Adjust the free travel if necessary (see under ”Checks
and Adjustments” on page 94).