Replacement Part List

ManualsBrandsVector ManualsRecreational Vehicles250 2WD 250cc UTV in Camo

PERIODIC SERVICE 11-17

4. Adding the LLC

1) Add only water if the mixture reduces in

amount by evaporation.

2) If there is a mixture leak, add the LLC of the

same manufacturer and type in the same

mixture percentage.

* Never add any long-life coolant of different

manufacturer.(Different brands may have

different additive components, and the

engine may fail to perform as specified.)

5. When the LLC is mixed, do not employ any

radiator cleaning agent. The LLC contains

anticorrosive agent. If mixed with the cleaning

agent, sludge may build up, adversely

affecting the engine parts.

6. The vehicle’s original long-life coolant has a

service life of 2 years. Be sure to change the

coolant every 2 years.

NOTE:

 The above data represents industry standards

that necessitate a minimum glycol content in

the concentrated antifreeze.

 When the coolant level drops due to

evaporation, add water only to keep the

antifreeze mixing ratio less than 50%. In case

of leakage, add antifreeze and water in the

specified mixing ratio before filling into the

radiator.

■ Replacing Radiator Hose (Water pipes)

Replace the hoses and clamps.

(See “Checking Radiator Hose and Clamp” in

“EVERY 200 HOURS” in “PERIODIC SERVICE”

section.)

■ Replacing Fuel Hose

Consult your local HISUN Dealer for this service.

■ Replacing Brake Master Cylinder (Inner

parts)

Consult your local dealer for this service.

■ Replacing Front Brake Seal

Consult your local dealer for this service.

■ Replacing Rear Brake Cylinder Seal

Consult your local dealer for this service.

■ Replacing Intake Air Line

Consult your local dealer for this service.

EVERY 4 YEARS

■ Replacing Brake Hose

Consult your local Dealer for this service.

■ Replacing Slow-Blow Fuses

The slow-blow fuses are intended to protect the

electrical cabling. If any of them have blown out, be

sure to pinpoint the cause.

◆ Replacing procedure

1) Disconnect the negative cable of the battery.

2) Open the slow-blow fuse box cover.

3) Pull out the slow-blow fuse.

4) Insert a new slow-blow fuse into the slow-blow

fuse box.

5) Close the slow-blow fuse box cover.

6) Connect the negative battery cable.

Summary of content (2 pages)

PAGE 1
PERIODIC SERVICE 11-17 ■ Replacing Brake Master Cylinder (Inner 4. Adding the LLC parts) 1) Add only water if the mixture reduces in Consult your local dealer for this service. amount by evaporation. 2) If there is a mixture leak, add the LLC of the ■ Replacing Front Brake Seal same manufacturer and type in the same Consult your local dealer for this service. mixture percentage. * Never add any long-life coolant of different manufacturer.
PAGE 2
PERIODIC SERVICE 11-18 ① Slow-blow fuse box cover ■ Replacing Light Bulb  Head lights Take the bulb out of the light body and replace it with a new one.