Full Product Manual

PERIODIC SERVICE 11-14
■ Checking Intake Air Line
1. Check to see if the hoses and hose clamps
are tight and not damaged.
2. If hoses and clamps are found to be worn or
damaged, replace or repair them at once.
① Hose ② Hose joint
EVERY 300 HOURS
■ Checking Tire
1. Check to see if tires are damaged.
2. If the tires are cracked, bulged, or cut, or they
are worn out, replace or repair them at once.
◆ Tire Tread Depth
Always replace the tires when the tread depth is
worn to minimum allowable.
① 3mm(0.12in)
EVERY 400 HOURS
■ Changing Transmission Fluid
CAUTION
To avoid personal injury:
 Park the vehicle on a flat surface, raise the
cargo bed, and mount the safety support.
 Allow engine to cool down sufficiently, oil
can be hot and can burn.
1. Park the vehicle on a flat surface, raise the
cargo bed, and mount the safety support.
2. To drain the used oil, remove the drain plug at
the bottom of the transmission case and drain
the oil completely into the oil pan.
3. After draining, reinstall the drain plug.
4. After running the engine for a few minutes,
stop the engine and check the oil level again;
add oil to prescribed level.
① Drain plug
IMPORTANT:
 Do not operate the vehicle immediately after
changing the transmission fluid.
 Run the engine at medium speed for a few
minutes to prevent damage to the
transmission.
■ Changing Front and Rear Axle Case Oil
1. Park the vehicle on a firm, flat and level
surface.
2. To drain the used oil, remove the drain plug
and drain the oil completely into the oil pan.
3. Fill with the new oil up to the upper notch on