Full Product Manual

Periodic Service
10-10
 When the battery is being activated,
hydrogen and oxygen gases in the
battery are extremely explosive.
Keep open sparks and flames away
from the battery at all times,
especially when charging the battery.
 When disconnecting the cable from
the battery start with the negative
terminal first; when connection the
cable to the battery start with the
positive terminal first.
 Always check battery charge by
using a voltmeter.
① Battery
1. To slow charge the battery connect the
battery positive terminal to the charger
positive terminal and the negative to the
negative. Recharge the battery using
the recharger instructions.
2. A boost charge is only for emergencies
it will partially charge the battery. A full
charge should be performed soon.
3. When exchanging an old battery for a
new one use battery of equal
specification shown in table 1.
Battery type
Volts
12V32Ah
12
◆Direction for storage
When storing the vehicle for a long period,
remove the battery from the vehicle, store in
a dry place out of direct sunlight.
1. The battery will self-discharge while it is
shored. Recharge it once every three
months in hot seasons and once every six
months in cold seasons.
■ Adjusting toe-in
Proper toe-in
0 to12 mm (0 to 0.47 in)
1. Park vehicle on flat place.
2. Turn steering wheel so front wheels are in
the straight ahead position.
3. Lock the park brake and stop the engine.
4. Measure distance between front tire beads
at rear of tire at hub height.
5. Front distance should be shorter than rear
distance if not adjust tie rod length.
Bench seat
① Wheel-to-wheel distance at front
② FRONT