Use and Care Manual

OPERATING INSTRUCTIONS
1. IMPORTANT:AlwaysoperatethecompressoratorbelowtheMAXIMUMPRESSURERATINGof
 thecompressor.PleaserefertoApplication&SpecicationsSectionsofthismanualfordetails.
2.AlwaysobservetheMAXIMUMDUTYCYCLEoftheaircompressor.RefertoCompressor
 ApplicationsandSpecicationsSectionsofthismanualfordetails.Operationexceeding
 maximumpressureratingsand/ordutycyclewillresultindamagetotheaircompressor.
3.Topreventdischargeofyourvehicle’sbattery,andenhanceperformance,ALWAYSkeepthe
 vehicle’senginerunningwhileusingthecompressor.
MAINTENANCE & REPAIRS
1.Periodicallycheckallelectricalandttingconnections.Cleanandtightenasneeded.
2.Periodicallycheckallmountingscrews.Tightenasneeded.
3. (P/N 00092 Only) Replaceairlterelementperiodically.Replacementfrequencydependson
 operatingfrequencyandoperatingenvironment.Forfrequentuseindustyenvironments,
 werecommendthatyoureplaceairlterelementatleastonceamonth.
4.Regularlycleandustanddirtfromcompressorcoolingnsandmotorhousing.
5.Youraircompressorisequippedwithpermanentlylubricated,maintenance-freemotor.
 Nevertrytolubricatecompressor.
6.AllrepairsshouldbeperformedbyManufacturerorManufacturer’sAuthorizedService
 Agenciesonly.
CAUTION:
Nevertouchtheaircompressororttingsconnectedtotheaircompressorwithbarehands
duringorimmediatelyafteruse.LeaderhoseandttingsconnectedtoLeaderHosewillbecome
veryhotduringandafteruse.Ifnecessary,wearheatresistantglovestohandlettings,airline,
and leader hose.
PLEASE NOTE:
Usethreadsealantforproperinstallation.Teontapeisnotrecommended.
Properlysealed,recommendedtorquefor1/8”NPTttingsis10to11ft.lbs.
USER MANUAL
90C - 92C - 95C Air Compressor Kit