Operation Manual

WWW.MANUALS.WS

1979 Volvo 242 244 245

application of the last paint coat, before the paint starts to dry.

Touching-up is as follows:

1 Remove paint flakes.

2 Sand the damaged surface and wash it clean with thinner.

Apply the rust remover. (Avoid contact with skin!) Wait a few minutes and then rinse carefully with

water and wipe dry.

3 Shake the spray can for at least 1 minute. Spray on the primer. Move the can slowly and evenly back

and forth, about 20-30 cm (8-12 inches) from the surface. Protect the surrounding surfaces with suitable

paper.

4 When the primer has dried, apply the surface enamel in the same way. Spray on several times and

allow the paint to dry a minute or so between each application.

pg. 76 Long distance trips

Prior to a long distance trip

Have your car checked at a Volvo dealer. Preventive maintenance will help to ensure a trouble free trip.

Remember to take along a Volvo dealer directory.

The main items to check are listed below:

1. Brakes, front wheel alignment and steering gear.

2. Engine running condition.

3. Fuel system operation.

4. Oil leaks: engine, transmission, rear axle.

5. Cooling system for leaks or worn hoses.

6. Examine tires carefully, replace worn tires.

7. Battery and terminals.

8. Tool equipment.

9. Lighting.

10. Drive belts for tightness and wear.

pg. 77 Cold weather

file:///K|/ownersdocs/1979/1979_242_244_245/79242244245_03c.htm (5 of 12)12/22/2006 10:24:34 PM