Cooker with gas oven and gas grill Instructions for installation and use K 642 G/G K 642 GS/G K 642R GS/G K 643 G/G K 6432 G/G K 645 G/G K 645R G/G K 647 GS/G K 647R G/G
Cooker with gas oven and gas grill Instructions for installation and use
Important safety warnings To maintain the EFFICIENCY and SAFETY of this appliance, we recommend: • use only the MANUFACTURER Service • use only ORIGINAL Spare Parts 1 This owner's manual is for a class 1 appliance (installed independently) or class 2 - sub-class 1 appliances (installed between two cabinets). 2 Before using the appliance, read the instructions in this owner’s manual carefully since you should find all the instruction you require to ensure safe installation, use and maintenance.
Installation The following instructions should be read by a qualified technician to ensure that the appliance is installed, regulated and technically serviced correctly in compliance with current regulations. Important: remember to unplug the appliance from the mains before regulating the appliance or carrying out any maintenance work.
Important: make sure the supply pressure conforms with the values shown in the table entitled“Caracteristics of the burners and nozzles”. When the cooker is installed between cabinets (recessed), the gas connection must be effected by an approved flexible hose with bayonet fitting (BS 669 Current Edition). The gas inlet for the cookers is a threaded G 1/2 gas female fitting. the mains cable must be wired into a cooker output point with a rating of 45 amp. In this case the cable is not supplied.
V c) Minimum regulation of the hob burners: • turn the tap to minimum; • remove the knob and adjust the regulation screw, which is positioned in or next to the tap pin, until the flame is small but steady. N.B.: in the case of liquid gas, the regulation screw must be screwed in to the bottom. • check that the flame does not turn off when you turn the tap quickly from high to low. d) Regulating the primary air of the burners: The primary air of the burners requires no regulation. Fig. C Fig.
Important: when mounting the grill burner check that there is a space of at least 4 mm between the security thermocouple (if installed) and the burner. Important On completion of the operation, replace the old rating sticker with one indicating the new type of gas used. This sticker is available from our Service Centres.
Burner and nozzle characteristics Table 1 Liquid Gas Burner Diameter (mm) Thermal Power kW (p.c.s.*) By-Pass 1/100 Nozzle 1/100 Natural Gas Flow* g/h Nozzle 1/100 Nominal Reduced (mm) (mm) *** ** (mm) Flow* l/h Fast (Large)(R) 100 3.00 0.7 41 86 218 214 116 286 Semi Fast (Medium)(S) 75 1.90 0.4 30 70 138 136 106 181 Auxiliary (Small)(A) 55 1.00 0.4 30 50 73 71 79 95 Triple Crown (TC) 130 3.25 1.5 63 91 236 232 133 309 Oven - 3.02 1.
Technical characteristics Mains frequency and voltage of the electric section and characteristics of the gas section Model Gas section Electric section Rated power kW (1) Class Voltage K 642 G/G K 642 GS/G K 642R GS/G K 643 G/G K 6432 G/G K 645 G/G K 645R G/G II2H3+ 10,82 (787 g/h - G30) (773 g/h - G31) 230V~ 50/60Hz K 647 GS/G K 647R G/G II2H3+ 12,17 (885 g/h - G30) (869 g/h - G31) 230V~ 50/60Hz (1) The values in g/h refer to the capacities with liquid gas (Butane, Propane).
The cooker with gas oven H A B C E D K M O P L N G M O Q L N M O P L N F A Tray for Catching Overflows B Gas Burner C Instantaneous Electronic Lighting Device (only a few models) D Top Grate E Control Panel F Adjustable Feet or Legs G Dripping Pan or Baking Sheet H Flame Failure Device for Cooktop Burners (only a few models) K Oven Rack L Electronic Lighting for Hob Burners (only a few models) M Oven Control Knob N Control Knobs for Gas Burners on Hob O Button for Oven and Rotisserie L
The different functions and uses of the oven The various functions included in the cooker are selected by operating the control devices located on the cooker control panel. during the period between the time of production and installation of the appliance. Control Knobs for the Gas Burners on the Hob The position of the gas burner controlled by each one of Attention: Only use the bottom shelf of the oven when using the rotisserie to cook (where present).
Oven light button (O) clockwise, till to the position “Max”. It is necessary to hold pressed in the knob for about 6 seconds in order to activate the flame failure device. To light on the grill burner press in the bottom marked and switchs on the light This is marked by the symbol inside the oven so that you can control the cooking without opening the door. by the symbol , press deeply and turn the oven knob counter clock wise till to the position (grill).
Cooking advice The oven offers a wide range of alternatives which allow you to cook any type of food in the best possible way. With time you will learn to make the best use of this versatile cooking appliance and the following directions are only a guideline which may be varied according to your own personal experience. I used more than one level and they are not all at the same cooking point Use a lower temperature setting. It is not necessary to remove the food from all the racks at the same time.
Cooker routine maintenance and cleaning Before each operation, disconnect the cooker from the electricity.To assure the long life of the cooker, it must be thoroughly cleaned frequently, keeping in mind that: · Do not use steam equipment to clean the appliance.
Pratical advice for oven cooking Food to be cooked Wt. (Kg) Cooking position of shelves from bottom Temperature (°C) Pre-heating time (min) Cooking time (min.) Pasta Lasagne Cannelloni Pasta bakes 2.5 2.5 2.5 3 3 3 210 210 210 15 15 15 75-80 75-80 75-80 Meat Veal Chicken Turkey Duck Rabbit Pork Lamb 1.7 1.5 3.0 1.8 2.0 2.1 1.8 3 3 3 3 3 3 3 230 220 Max 230 230 230 230 15 15 15 15 15 15 15 85-90 110-115 95-100 120-125 105-110 100-110 90-95 Fish Mackerel Dentex Trout baked in paper 1.1 1.
Merloni Elettrodomestici Cucina con forno e grill gas 09/02 - 195026721.05 Xerox Business Services - Docutech Viale Aristide Merloni 47 60044 Fabriano Italy Tel +39 0732 6611 Fax +39 0732 662501 www.merloni.