Service Manual
Table Of Contents
- Whirlpool & Maytag 27" Front-Load Gas & Electric Dryers
- Table of Contents
- Section 1: General Information
- Section 2: Diagnostics & Troubleshooting
- Section 3: Component Testing
- Testing - Safety Information
- Component Locations - Whirlpool
- Wiring Diagram - Whirlpool Electric
- Wiring Diagram - Whirlpool Gas
- Wiring Diagram - Maytag Electric
- Wiring Diagram - Maytag Gas
- Component Testing
- TEST #1: ACU Power Check
- TEST #2: Supply Connections
- TEST #3: Motor Circuit
- TEST #4: Heat System
- TEST #4a: Thermistors
- TEST #4b: Thermal Fuse
- TEST #4c: Thermal Cut-Off
- TEST #4d: Gas Valve (Gas Dryer)
- TEST #5: Moisture Sensor
- TEST #6: Buttons & Indicators
- TEST #7: Door Switch
- TEST #8: Drum LED
- TEST #9: Water Valve
- Section 4: Component Access
- Component Locations - Whirlpool
- Door Reversal - Round Shaped Doors
- Door Reversal - Square Shaped Doors
- Removing the Top Panel & Console/HMI
- Removing the Appliance Control Unit (ACU)
- Removing the Front Panel & Door Switch
- Removing the Drum Light & Moisture Sensor
- Removing the Belt, Drum, and Rollers
- Removing the Drive Motor
- Removing the Thermal Fuse & Outlet Thermistor
- Removing the Heater, High Limit Thermostat & Thermal Cutoff
- Removing the Ignitor, Flame Sensor, High-Limit Thermostat and Thermal Cutoff (Gas Models)
- Removing the Gas Burner Assembly Coils (Gas Models)
- Removing the Rear Panel
- Removing the Water Valve
- Section 5: Connectivity
- Product Specifications & Warranty Info
1-10
n
Whirlpool & Maytag Front-Load Dryers
GENERAL INFORMATION
Product Specifications
ELECTRICAL
Fuel Type (Electric) : 240 VAC, 60 Hz, 30 Amp Service
Fuel Type (Gas) : 120 VAC, 60 Hz, 15-20 Amp Service
PRIMARY FEATURES*
Capacity : 7.3 cu. . (Maytag)
7.4 cu. . (Whirlpool)
Control Panel : (Whirlpool) Front Console / Capacive Touch / Electronic
(Whirlpool) Screen In Door / LCD Screen / Touch Screen
(Maytag) Front Console/ Indicator Lights / Cycle Select Knob
Drum Material : Powder Coat / Stainless Steel
Drum Design : Quad Liers
Door Style : Side Swing, Reversible, Window
Interior Light : Select Models
Energy Star® Qualied : Yes
Steam : Select Models
Cycles : Varies depending on model
Temperatures : Varies depending on model
Dryness Levels : (3) Less, Normal, More
Check Vent Indicator : Yes
EcoBoost™ Energy Saver : Yes
Cycle Time Remaining : Yes
Moisture Sensor : Yes
Smart Appliance/Remote Control : Select Models
INSTALLATION CONSIDERATIONS
Pedestal Opons : Yes
Stackable : Yes
Venng Direcon : 4-Way (Le, Right, Boom, Rear)
Maximum Vent Length : 64 .
OPTIONS*
Control Lock : Locks the controls of the dryer
Cycle Signal : Sound when cycle is complete
Damp Dry Signal : Sound when load is damp, but not completely dry
Eco Boost™ : Use a slightly lower heat level to increase energy savings
Reduce Stac : Introduces a small amount of moisture to reduce stac
Wrinkle Shield™/Prevent : Adds up to 150 minutes of periodic tumbling to reduce wrinkling
Wrinkle Shield™/Prevent with Steam: Adds up to 150 minutes of periodic tumbling w/steam to reduce wrinkling
DIMENSIONS
Height : 38 3/4” (98.4 cm)
Width : 27” (68.58 cm)
Depth : 31” (78.74 cm)
Gross Weight : 175 lbs. (79.37 kg)
* Features and Opons vary by brand and model.