Installation Guide

ManualsBrandsWOODBRIDGE ManualsBathElsey 59 in. Acrylic FlatBottom Double Ended Bathtub with Polished Chrome Overflow and Drain Included in White

WOODBRIDGE

READ ALL INSTRUCTIONS BEFORE UNPACKING THE PRODUCT

2 PEOPLE ARE REQUIRED TO LIFT AND DURING

ENTIRE INSTALLATION OF THIS PRODUCT

INSTRUCTIONS THAT, IF IGNORED COULD RESULT IN DEATH OR SERIOUS INJURY CAUSED BY INCORRECT HANDLING

OR INSTALLATION OF THE PRODUCT. THESE INSTRUCTIONS MUST BE OBSERVED FOR SAFE INSTALLATION.

This products must be installed by a fully insured and licensed plumber only. Installaon of any our product by anyone other

than fully insured and licensed plumber shall void limited warranty. We recommends that such licensed plumber have experience

in the installaon of products.

Limited warranty is void on any commercial installaon

We are not responsible for local code compliance for this product. Building and plumbing codes may vary from state-to-state in

accordance to your locaon. We are not resonsible for providing any compliance cerﬁcaons.

Under no circumstances we are shall not be liable for any and all incidental damages sustained in connecon with this product

Neither manufacture, nor distributor, nor retailer is responsible for water damage or ﬂood caused due to use of this product.

Under no circumstances We shall not be liable for any and all fees, cost of installaon/reinstallaon/removal, subsequent

damage or transportaon in case of the product defect

INSTALLATION AND CARE GUIDE

PREFERED

EDUCATION

PROVIDER

LISTED

ICC

• 2015 Uniform Plumbing Code ( UPC )

• 2018 International Plumbing Code ( IPC )

• 2018 International Residential Code ( IRC )

• CSA B45.5 / IAPMO Z124-2017- Plastic Plumbing Fixtures

Compliance with the following codes & standard:

Customer Service Phone: 562-229-0088. (Monday - Friday 9 AM - 5 PM Paciﬁc Time)

Or Email: help@woodbridgebath.com

SCC Accredited

CB-P/S

OCPS

Accrédité CCN

ANSI

ACCREDITED

ISO/IEC 17065

Product Certification Body

#1000

20200805 REV. 2

FREESTANDING BATHTUB

www.woodbridgebath.com

Summary of content (11 pages)

PAGE 1
INSTALLATION AND CARE GUIDE FREESTANDING BATHTUB Compliance with the following codes & standard: ® • 2015 Uniform Plumbing Code ( UPC ) ® • 2018 International Plumbing Code ( IPC ) ® • 2018 International Residential Code ( IRC ) • CSA B45.
PAGE 2
R R TOOLS REQUIRED FOR INSTALLATION (NOT INCLUDED) E G D E G OTHER TOOLS MAY BE REQUIRED So Cloth or Blanket Silicone Safety Glass Knife Tape Measure Level Pencil/Marker D I R Hammer B D Adjustable Wrench Caulk Gun O O W Channel Lock Pliers Inspect the bathtub for any damages. If any damage is found please contact your retailer. Carefully, remove the tub from it’s crate/box. Important Note: Bathtub must be carried by a minimum of 2 adult people in upside down posi on only.
PAGE 3
R E G D R R E G INSTALLATION WITH UNDERFLOOR ACCESS D I R B D O O W E G D R E G 1. Clean, level and prepare the floor for installa on, Place the tub in the exact installed loca on on the floor and trace the outline of the bathtub with pencil and mark the drain hole loca on on the floor. Move the tub away so that the plumbing can be installed. R E G D D I R B D O O W TOP R Moving blanket SOFT BLANKET E G B D D I R 2.
PAGE 4
R E G D W R E G 1/8” Tub wall D I R Tub feet leveler B D O O W 3. Place a level across the bo om of the tub and adjust the tub feet leveler to touch the level. Then raise the leveler addi onal 1/8” or 3/16” so that the weight of the tub, water and user are fully supported by the feet adjuster and not the tub walls. 4. Install an 1-1/2" tail piece along with the corresponing flanged washer and 1-1/2" nut to thedrain body. 5.
PAGE 5
6. Apply a generous bead of adhesive or waterproof silicone to the bo om of the tub and a bead of tub and le caulk around the edge of the tub 7. Flip the tub over and carefully set the tub into posi on with tail piece assembly to P-trap and connect to the drain. 8. Fill the tub with water to the overflow and then drain the tub while inspec ng the waste and overflow connec on below the floor for any leaks. Access from below will be necessary for this step. www.woodbridgebath.
PAGE 6
9. With the tub now set in place, wipe oﬀ any excess tub or le caulking, adhesive where the tub meets the floor with wet cloth. 10. DO NOT SHOWER or MOVE the tub a er installa on because it will take about 24 hours to get the silicone sealant to dry. Note: If installing on a concrete slab where no underfloor access or cannot move drain. You may consider following op on.
PAGE 7
O O W INSTALLATION ON SLAB FLOOR (NO UNDERFLOOR ACCESS) R E G D E G D I R B D O O W 1. Clean, level and prepare the floor for installa on, Place the tub in the exact installed loca on on the floor and trace the outline of the bathtub with pencil and mark the drain hole loca on on the floor. Move the tub away so that the plumbing can be installed. R E G D R E G D R E G D I R TOP B D O O W SOFT BLANKET R Moving blanket R E G 2.
PAGE 8
1/8” Tub wall Tub feet leveler 3. Place a level across the bo om of the tub and adjust the tub feet leveler to touch the level. Then raise the leveler addi onal 1/8” or 3/16” so that the weight of the tub, water and user are fully supported by the feet adjuster and not the tub walls. 4. Measure the actual distance from drain into drain pipe on floor and the drain pipe should extend approximately 1” above the finish floor. Use a drain adapter (not provided) if necessary. Floor surface 5.
PAGE 9
6. Install 1 ½” rubber slip gasket over the drain waste vent. 7. Apply a generous bead of adhesive or waterproof silicone to the bo om of the tub and caulk around the edge of the tub. 8. Flip the tub over and carefully set the tub into posi on with tail piece assembly to waste vent and connect to the drain. www.woodbridgebath.
PAGE 10
9. With the tub now set in place, wipe oﬀ any excess tub or le caulking, adhesive where the tub meets the floor with wet cloth. 10. DO NOT SHOWER or MOVE the tub a er installa on because it will take about 24 hours to get the silicone to dry. www.woodbridgebath.
PAGE 11
IMPORTANT SAFETY RULES ATTENTION! ALWAYS FOLLOW THESE PRECAUTIONS WHEN USING A BATHTUB Warning The bathtub must be installed and used as described in this manual Warning Use cau on when entering or exi ng the bathtub Warning Do not permit children or persons with infirmi es to use the bathtub without supervision of an adult Warning People using any medica ons or having adverse medical history must consult a physician prior to use of the bathtub to avoid poten al hyperthermia and possible drowning Warning Wa