Installation Sheet

ManualsBrandsZurn ManualsPlumbingAquaVantage 1.6 GPF Manual Toilet Flushometer Valves for Top Spud

AquaVantage AV

Hydraulic Flush Valves

AquaVantage

ZH Series

Hydraulic-Operation Flush Valve

Installation, Operation,

Maintenance, and Parts Manual

Patented and Patents Pending

Hydraulic-Operation

Closet/Urinal Systems

ZH6000AV

ZH6001AV

ZH6003AV

ZH6010AV

ZH6017AV

ZH6140AV

ZH6142AV

ZH6150AV

ZH6152AV

ZH6190AV

ZH6195AV

ZH6003AV

ZH6152AV

LIMITED WARRANTY

All goods sold hereunder are warranted to be free from defects in material and factory workmanship for a period of three years from the date of

purchase. Decorative finishes warranted for one year. We will replace at no cost goods that prove defective provided we are notified in writing of such

defect and the goods are returned to us prepaid at Sanford, NC, with evidence that they have been properly maintained and used in accordance with

instructions. We shall not be responsible for any labor charges or any loss, injury, or damages whatsoever, including incidental or consequential damages.

The sole and exclusive remedy shall be limited to the replacement of the defective goods. Before installation and use, the purchaser shall determine

the suitability of the product for his intended use and the purchaser assumes all risk and liability whatever in connection therewith. Where permitted by

law, the implied warranty of merchantability is expressly excluded. If the products sold hereunder are “consumer products,” the implied warranty of

merchantability is limited to a period of three years and shall be limited solely to the replacement of the defective goods. All weights stated in our

catalogs and lists are approximate and are not guaranteed.



ADA



ADA

FV241 Page 1

Summary of content (8 pages)

PAGE 1
AquaVantage AV ZH Series ® Hydraulic-Operation Flush Valve Installation, Operation, Maintenance, and Parts Manual Patented and Patents Pending AquaVantage AV Hydraulic Flush Valves ZH6003AV ADA Hydraulic-Operation Closet/Urinal Systems ZH6000AV ZH6001AV ZH6003AV ZH6010AV ZH6017AV ZH6140AV ZH6142AV ZH6150AV ZH6152AV ZH6190AV ZH6195AV ZH6152AV ADA LIMITED WARRANTY All goods sold hereunder are warranted to be free from defects in material and factory workmanship for a period of three years from the da
PAGE 2
AquaVantage AV Hydraulic Flush Valves AquaVantage ® Valve Rough-In, Product Specifications, Models, and Options PRODUCT SPECIFICATIONS: ZURN AquaVantage® ‘AV’ ZH Series Exposed/Concealed Flush Valve – Exposed/concealed, quiet diaphragm-type, chrome plated/rough brass, flushometer valve with Zurn’s AquaVantage TPE, chloramine resistant, dual seal diaphragm with surface optimization and clog resistant dynamic orifice.
PAGE 3
Sweat Solder Adaptor Installation Instructions for Exposed Valves Important: • All plumbing is to be installed according to state and local codes and regulations. • Water supply lines need to allow proper water flow for each fixture. • Flush all lines of any debris before making connections. • Do not use pipe sealant or plumbing grease on any fitting other than the control stop inlet. Figure A STEP NO.
PAGE 4
AquaVantage ® Valve Installation Instructions for Exposed ZH Series STEP 1 Control Stop Installation (Figure 1) Install the Zurn control stop valve with “Siphon Guard” back check protection (and wall escutcheon on exposed flushometer installations) to the water supply line with outlet positioned as required. Note: For sweat solder applications, see recommended instructions on Page 3 or refer to those included in the Zurn sweat solder kit.
PAGE 5
AquaVantage ® Valve Installation Instructions for Exposed ZH Series STEP 4 Install push button actuator. STEP 5 Flush out supply line (Figure 6). Make sure the control stop is closed. Remove flushometer cover. Lift out the diaphragm kit assembly. Install the flushometer cover, wrench tight and open stop. Turn on water supply to flush line of any debris or sediment. STEP 6 Adjust Control Stop Adjust the control stop to meet the flow rate required for proper cleaning of the fixture.
PAGE 6
AquaVantage ® Hydraulic-Operated Repair Kits AquaVantage AV Hydraulic Flush Valves Parts Identification 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. 21. 22. 23. 24. 25. 26. 27. 28. 29. 30. 31. 32. 33. 34. 35. 36. 37. 38. 39. 40. 41. 42. 43. 44. 45. 46.
PAGE 7
AquaVantage ® Hydraulic-Operated Service and Maintenance PROBLEM CAUSE CORRECTIVE ACTION Valve will not operate. 1. 2. 3. 4. 5. 1. 2. 3. 4. 5. Insufficient volume of water to adequately evacuate fixture. 1. Stop valve is not open enough. 2. Urinal trip mechanism installed in closet valve. Water supply is shut off. Internal valve filter is plugged. Tubing is hooked up improperly. Plunger orifice is clogged. Damaged or worn seals in HYM Actuator. Turn on water supply/stop valve.
PAGE 8
AquaVantage AV Hydraulic Flush Valves ZURN INDUSTRIES, INC. COMMERCIAL BRASS OPERATION, 5900 ELWIN BUCHANAN DRIVE, SANFORD, NC, U.S.A. 27330 PHONE: 1-800-997-3876 FAX: 919/775-3541 WEBSITE: www.zurn.com ZURN INDUSTRIES LIMITED 3544 NASHUA DRIVE, MISSISSAUGA, ONTARIO L4V 1L2 PHONE: 905/405-8272 FAX: 905/405-1292 © 2004 Zurn Industries, Inc. Printed in the U.S.A. Form No.