Report No.: 16PNS09049 01001 Safety Data Sheets Name of Goods: Polymer Lithium Battery Commissioner: SHENZHEN BIYATE ENERGY CO., LTD Dongguan UTL Electronic Technology Co., Ltd.
Page 2 of 23 Report No.: 16PNS09049 01001 Safety Data Sheet (SDSs) Name of goods Polymer Lithium Battery Mode 301429 Type 3.7V, 100mAh, 0.37Wh Commissioned by Commissioner address Manufacturer Manufacturer address Factory Factory address Inspection according to SHENZHEN BIYATE ENERGY CO., LTD Bldg B-14B,The First Industrial Zone, Baihua Community, Guangming New District, Shenzhen, China. SHENZHEN BIYATE ENERGY CO.
Page 3 of 23 Report No.: 16PNS09049 01001 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING Product Identifier Product name： Polymer Lithium Battery Model： 301429 3.7V, 100mAh, 0.37Wh Other means of identification Synonyms： None Recommended use of the chemical and restrictions on use Recommended Use： LITHIUM ION BATTERIES Uses advised against： No information available Details of the supplier of the safety data sheet Supplier Name SHENZHEN BIYATE ENERGY CO.
Page 4 of 23 Report No.: 16PNS09049 01001 Emergency Overview Signal word Danger Hazard Statements Causes severe skin burns and eye damage May cause an allergic skin reaction May cause cancer Causes damage to organs through prolonged or repeated exposure This product is an article which contains a chemical substance. Safety information is given for exposure to the article as sold. Intended use of the product should not result in exposure to the chemical substance. This is a battery.
Page 5 of 23 Report No.: 16PNS09049 01001 Inhalation IF INHALED: Remove victim to fresh air and keep at rest in position comfortable for breathing Immediately call a POISON CENTER or doctor/physician Ingestion IF SEALLOWED: Rinse mouth.
Page 6 of 23 Report No.: 16PNS09049 01001 3. COMPOSITION/INFORMATION ON INGREDIENTS Common Chemical Name Chemical Formula Concentration (%) CAS Number LiCoO2 30 12190-79-3 C 20 1333-86-4 C24X12 0.8 7782-42-5 (C2H2F2)n 0.8 24937-79-9 Aluminum foil Al 3 7429-90-5 Carboxymethyl cellulose -- 0.3 9004-32-4 Styrene-butadiene rubber (C8H8.C4H6)x 0.3 9003-55-8 Cu 6 7440-50-8 Polypropylene (C3H6)n 1.0 9003-07-0 Polyethylene (C2H4)n 1.
Page 7 of 23 Eye Contact Report No.: 16PNS09049 01001 Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Keep eye wide open while rinsing. Do not rub affected area. Remove contact lenses, if present and easy to do. Seek immediate medical attention/advice. Skin Contact Wash off immediately with soap and plenty of water while removing all contaminated clothes and shoes. May cause an allergic skin reaction. Seek immediate medical attention/advice.
Page 8 of 23 Report No.: 16PNS09049 01001 Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable extinguishing media CAUTION: Use of water spray when fighting fire may be inefficient. Specific Hazards Arising from the Chemical The product causes burns of eyes, skin and mucous membranes. Thermal decomposition can lead to release of irritating gases and vapors. Product is or contains a sensitizer.
Page 9 of 23 Report No.: 16PNS09049 01001 Methods for Containment Prevent further leakage or spillage if safe to do so. Methods for Cleaning up Pick up and transfer to properly labelled containers. 7. HANDLING AND STORAGE Precautions for safe handling Handling In case of rupture: Handle in accordance with good industrial hygiene and safety practice. Avoid contact with skin, eyes or clothing. In case of insufficient ventilation,wear suitable respiratory equipment.
Page 10 of 23 TWA: 2.5 mg/m3 F Phosphate(1-), hexafluoro-, lithium 21324-40-3 Report No.: 16PNS09049 01001 TWA: 2.5 mg/m3 F TWA: 2.5 mg/m3 dust (vacated)TWA: 2.5 mg/m3 Copper TWA: 0.2 mg/m3 fume TWA:0.1 mg/m3 fume 7440-50-8 TWA: 1 mg/m3 dust and mist TWA: 1 mg/m3 dust and mist (vacated)TWA: 0.
Page 11 of 23 Report No.: 16PNS09049 01001 Chemical resistant apron. Impervious gloves. Respiratory protection If exposure limits are exceeded or irritation is experienced, NIOSH/MSHA approved respiratory protection should be worn. Positive-pressure supplied air respirators may be required for high airborne contaminant concentrations. Respiratory protection must be provided in accordance with current local regulations.
Page 12 of 23 Report No.
Page 13 of 23 Report No.: 16PNS09049 01001 Information on likely routed of exposure Product Information Product does not present an acute toxicity hazard based on known or supplied information. In case of rupture Inhalation Specific test data for the substance or mixture is not available. Corrosive by inhalation. (based on components). Inhalation of corrosive fumes/gases may cause coughing, choking, headache, dizziness, and weakness for several hours.
Page 14 of 23 Symptoms Report No.: 16PNS09049 01001 Erythema (skin redness). Burning. May cause blindness. Coughing and/ wheezing. Itching. Rashes. Hives Delayed and immediate effects as well as chronic effects from short and long-term exposure Sensitization May cause sensitization by skin contact. Mutagenic Effects No information available. Carinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen.
Page 15 of 23 Report No.: 16PNS09049 01001 STOT – repeated exposure Chronic Toxicity Chronic exposure to corrosive fumes/gases may cause erosion of the teeth followed by jaw necrosis. Bronchial irritation with chronic cough and frequent attacks of pneumonia are common. Gastrointestinal disturbances may also be seen. Contains a known or suspected carcinogen. Avoid repeated exposure. Prolongled exposure may cause chronic effects. May cause adverse liver effects. Target Organ Effects Respiratory system.
Page 16 of 23 Report No.: 16PNS09049 01001 Copper 7440-50-8 96h EC50: 0.0310.054mg/L (Pseudokirchneriella subcapitata) 72h EC50: 0.0426-0.0535 mg/L (Pseudokirchneriella subcapitata) 96h LC50: 0.00680.0156 mg/L (Pmephales promelas) 96h LC50:=1.25 mg/L (Lepomis macrochirus) 96h LC50:=0.052 mg/L (Oncorthynchus mykiss) 96h LC50:=0.2mg/L(pim ephales promelas) 96h LC50:<0.3 mg/L(pimephales promelas) 96h LC50:=0.112mg/L(p imephales promelas) 96h LC50:=0.112 mg/L(poecilia reticulate) 96h LC50:=0.
Page 17 of 23 Report No.: 16PNS09049 01001 otherwise altered. Consult 40 CFR 261 to determine whether the altered material is a hazardous waste. Consult the appropriate state, regional, or local regulations for additional requirements Contaminated Packaging Dispose of contents/containers in accordance with local regulations.
Page 18 of 23 Hazard Class N/A Emergency Response Guide Number 147 TDG Not regulated MEX Not regulated ICAO Not regulated IATA Not regulated Proper Shipping Name NOT REGULATED Hazard Class N/A IMDG/IMO Report No.: 16PNS09049 01001 Not regulated Hazard Class N/A EmS-No. F-A, S-I RID Not regulated ADR Not regulated ADN Not regulated 15.
Page 19 of 23 Chemical name Report No.: 16PNS09049 01001 CAS No Weight-% SARA 313-Threashold Values % 12190-79-3 30-60 0.1 Copper – 7440-50-8 7440-50-8 7-13 1.0 Aluminum – 7429-90-5 7429-90-5 5-10 1.0 Nickel – 7440-02-0 7440-02-0 1-5 0.
Page 20 of 23 Report No.: 16PNS09049 01001 US State Regulations California Proposition 65 This product contains the following Propositions 65 chemicals Chemical name California Proposition 65 Carbon black – 1333-86-4 Carcinogen Nickel – 7440-02-0 Carcinogen U.S.
Page 21 of 23 Report No.: 16PNS09049 01001 Canada WHMIS Hazard Class Non-controlled 16. OTHER INFORMATION NFPA Health Hazards 1 Flammability 0 Instability 0 NFPA Health Hazards 1 Flammability 0 Instability 0 Physical and Chemical HazardsPhysical and HMIS Health Hazards 0 Flammability 0 Instability 0 Personal Protection X Prepared By Product Stewardship 23 British American Blvd.
Page 22 of 23 Report No.: 16PNS09049 01001 Photos Fig.1 Overall view I of battery Dongguan UTL Electronic Technology Co., Ltd. 1F, Hengzheng Bldg, North Road of Station, Nancheng District, Dongguan, Guangdong, China Tel:+86-769-3893 3228 Fax:+86-769-3893 3229 E-mail: sales@gdutl.
Page 23 of 23 Report No.: 16PNS09049 01001 Fig.2 Overall view II of battery Dongguan UTL Electronic Technology Co., Ltd. 1F, Hengzheng Bldg, North Road of Station, Nancheng District, Dongguan, Guangdong, China Tel:+86-769-3893 3228 Fax:+86-769-3893 3229 E-mail: sales@gdutl.
