Use Manual

Probable cause Corrective action
The rechargeable lithium battery is defective. 1. Remove the CAR from the track.
CAUTION: Wear personal protective
equipment while operating the laboratory
automation system.
2. Contact an Abbott Laboratories representative or
an authorized service representative.
Related information...
CAR observed problems, page 289
CAR lurches from side to side and is not stopped at the AccessPoint
Probable cause Corrective action
• The sliders are no longer present on the CAR.
• The guiding pin has broken off the CAR.
Replace the front underseal. Perform Replace the front
underseal of a CAR, page 303.
Related information...
CAR observed problems, page 289
CAR LEDs blink in an uncontrolled manner (such as red and yellow) while moving
Probable cause Corrective action
The CAR requires a restart. 1. Switch off the CAR, and then switch it on again.
2.
Contact an Abbott Laboratories representative or
an authorized service representative if necessary.
Related information...
CAR observed problems, page
289
CAR always moves at a constant speed
Probable cause Corrective action
The CAR does not detect any commands from the active
lane elements.
• Clean the CAR. Perform one or more of the
following procedures:
– Clean the sensors, page 197
.
– Clean the housing, page 198.
– Clean the charging contacts, page 198.
– Clean the sample holder, page 199.
– Clean the drive wheel and the wheel arch,
page 199.
• If necessary, replace the CAR. Perform one of the
following procedures:
– Replace a CAR with a sample, page 304.
– Replace a CAR without a sample, page 305.
Troubleshooting
Observed problems Section 10
292 GLP systems Track Operations Manual
80003968-101 DRAFT - 2022-03-11
DRAFT 2022-03-11