User guide
Table Of Contents
- Record of Revisions
- Service Bulletin List
- List of Effective Pages
- Table of Contents
- List of Figures
- Introduction
- Description and Operation
- Test and Fault Isolation
- 1. Inspection and Test Regulatory Requirements
- 2. Inspection and Test Procedures
- A. Checklist
- B. Preparation
- C. Coax Cable and Wiring Connections Inspection – Item 1
- D. Mounting Tray and Hardware Inspection – Item 2
- E. Battery Pack Inspection – Item 3
- F. G-Switch Functional Check – Item 4
- G. Performance Testing Setup
- H. 121.5 MHz Frequency Measurement – Item 5a
- I. Audio Modulation Check – Item 5b
- J. 121.5 MHz Power Output Measurement – Item 5c
- K. 406 MHz Frequency Measurement – Item 5d
- L. 406 MHz Power Output Measurement – Item 5e
- M. Current Draw Test – Item 5f
- N. Digital Message Verification – Item 5g
- O. ELT Reset Check – Item 5h
- P. Installed Transmitter Test – Item 6
- Q. Antenna Test – Item 7
- R. Inspection and Test Documentation – Item 8
- 3. Fault Isolation
- Removal
- Installation
- 1. Regulatory Requirements and Guidelines
- 2. Mounting Tray
- 3. Antenna
- 4. Remote Switch
- 5. Buzzer
- 6. Wiring
- A. General Considerations and Recommendations
- B. Remote Switch Harness Fabrication
- C. ELT D-Sub Plug Installation
- D. Cockpit Remote Switch 9-Pin Plug Installation
- E. Wiring Installation
- F. Antenna Connection
- G. Cockpit Remote Switch Power Connection
- H. Remote Switch Alternate Power Source
- I. Airframe Ground Connections
- J. Buzzer Connections
- K. Remote Switch Final Installation
- 7. ELT Installation
- 8. Battery Pack Installation
- 9. Helicopter Installations - Special Considerations
- Appendix A – ELT Registration
- Illustrated Parts List
25-62-30
Page 19 of 84
Jun 25/13
ARTEX PRODUCTS / ACR ELECTRONICS, INC
DESCRIPTION, OPERATION, INSTALLATION AND MAINTENANCE MANUAL
ME406 (453-6603), ME406HM (453-6604)
RTCA Radio Technical Commission for Aeronautics – Organization that
makes recommendations for airworthiness. Refer to
www.rtca.org/aboutrtca.asp
for more information.
RTV A rubbery silicon-based adhesive typically used to prevent vibration
problems and water intrusion.
SAR Search and Rescue
SCREEN ROOM The term “Screen Room”, within the context of this document, refers
to a room designed to suppress RF signals, such that the broadcast of
an ELT placed in the screen room cannot reach the SAR satellite sys-
tem.
SERVICE LOOP A length of wire or cable, at the connection point, of sufficient length
to allow a component to be withdrawn from its mounting position and
disconnected from its associated wiring.
TETHER A tether is a cord or similar device that anchors something movable
to a stationary point or anchors two items together, such that they
cannot become separated beyond the length of the tether.
TSO Technical Standard Order – A TSO is a minimum performance stan-
dard issued by the FAA for specified materials, parts, processes, and
appliances used on civil aircraft.
UTC Coordinated Universal Time – A time standard based on International
Atomic Time. UTC is the time system used in aviation and is often
associated with Greenwich Mean Time (GMT) and/or “Zulu” time.
VHF Very High Frequency – The 30 MHz to 300 MHz radio frequency band.
VSWR Voltage Standing Wave Ratio – Electrical signals will “echo” back on a
wire if load impedance is not matched to the impedance of the wire.
VSWR is a measurement of the amount of voltage being “echoed,”
compared to the original signal.