Repair Manual

REPAIR MANUAL
0
General
TECHNICAL CHARACTERISTICS
MOVEMENT TRANSMISSION
• Gear type: continuous variable transmission
• Clutch type: centrifugal
• Control mode: automatic
• Transmission type:
Engine → regulator → reverser reducer axle → wheels.
• Maximum speed: 45km/h light quadricycle category L6e
• Maximum speed: 75km/h heavy quadricycle category L7e.
SUSPENSION
• Front: independent wheels, pseudo Mac Pherson type, double effect hydraulic telescopic shock absorbers and helical springs.
• Rear: independent wheels with pulled arms, double effect hydraulic telescopic shock absorbers and helical springs.
STEERING
• Steering type: rack
BRAKING
CHARACTERISTICS
FRONT
REAR
Type Discs Drums
Diameter 210 mm 160 mm
• Service brake
The front and rear linings are driven by hydraulic pistons controlled by a double circuit master cylinder. This master cylinder, which
includes a brake fluid tank in its upper section, is controlled from inside the vehicle by a pedal within reach of the driver's right foot.
A limiter allows automatic reduction of braking effectiveness on the rear axle.
• Emergency brake
A lever located near the driver's right hand, between both vehicle seats, actuates the rear brakes, by means of a
cross-bar with two cables. This brake is adjusted mechanically by a screw on the level of each rear wheel or the cross-
bar. A pawl allows to hold this brake in the applied position.
BODY:
• Body: light engine-powered quadricycle (L6e), heavy engine-powered quadricycle intended for transporting persons (L7e)
• Materials making up the body:
thermoformed ABS
• Number of seats: 2 light quadricycle category L6e, 4 heavy quadricycle category L7e
• Seats: 2 and bench seat Heavy quadricycle category L7e
• Number of doors: 2
• Nature of materials used for windows:
- Windshield: laminated glass
- Side windows: tempered glass
- Rear window: tempered glass
LIGHTING AND SIGNALING
• Headlights:
- indicators: 12V/21W
- position lights: 12V/21W
- low and high beam 12V/50W/60W
• Rear lights:
- rear and stop lights: 12V/21W/5W
- fog lights: 12V/21W
- backup lights: 12V/21W
• Front fog lights:
- fog lights: 12V/35W
• Day lights:
-LED lights: 12V/ 4W