cPCI-3E10 Series 3U CompactPCI 4/2 Port Gigabit Ethernet Card User’s Manual Manual Rev.: 2.00 Revision Date: November 15, 2011 Part No: 50-15073-1000 Advance Technologies; Automate the World.
Revision History ii Revision Release Date 2.
cPCI-3E10 Preface Copyright 2011 ADLINK Technology Inc. This document contains proprietary information protected by copyright. All rights are reserved. No part of this manual may be reproduced by any mechanical, electronic, or other means in any form without prior written permission of the manufacturer.
Using this Manual Audience and Scope The cPCI-3E10 User’s Manual is intended for hardware technicians and systems operators with knowledge of installing, configuring and operating industrial grade single board computers. Manual Organization This manual is organized as follows: Chapter 1, Introduction: Introduces the cPCI-3E10 Series, its features, specifications and block diagrams. Chapter 2, Board Interfaces: Describes the cPCI-3E10 board interfaces, pin definitions, and jumper settings.
cPCI-3E10 Conventions Take note of the following conventions used throughout this manual to make sure that users perform certain tasks and instructions properly. Additional information, aids, and tips that help users perform tasks. NOTE: CAUTION: WARNING: Preface Information to prevent minor physical injury, component damage, data loss, and/or program corruption when trying to complete a task.
This page intentionally left blank.
cPCI-3E10 Table of Contents Revision History...................................................................... ii Preface .................................................................................... iii List of Figures ........................................................................ ix List of Tables.......................................................................... xi 1 Introduction ........................................................................ 1 1.1 Overview.........
This page intentionally left blank.
cPCI-3E10 List of Figures Figure 1-1: Figure 1-2: Figure 1-3: Figure 2-1: Figure 2-2: Figure 2-3: Figure 2-4: Figure 2-5: Figure 2-6: Figure 2-7: Figure 2-8: cPCI-3E10 Block Diagram ............................................... 3 cPCI-3E12 Block Diagram ............................................... 4 cPCI-3E10-SUB Block Diagram ...................................... 4 cPCI-3E10 Board Layout ................................................. 5 cPCI-3E10 Front Panel.......................................
This page intentionally left blank.
cPCI-3E10 List of Tables Table 1-1: Table 2-1: Table 2-2: Table 2-3: Table 2-4: Table 2-5: List of Tables cPCI-3E10 Specifications ................................................ 2 RJ-45 Pin Definitions ....................................................... 9 LAN Status LED Definitions............................................. 9 DB-9 LAN1/2 Connector Pin Definition.......................... 10 CompactPCI J1 Connector Pin Definition...................... 11 CompactPCI J2 Connector Pin Definition.....
This page intentionally left blank.
cPCI-3E10 1 Introduction 1.1 Overview The cPCI-3E10 Series is 3U CompactPCI Gigabit Ethernet peripheral card equipped with Intel® 82574L PCIe Gigabit Ethernet controllers. The cPCI-3E10 provides four GbE ports on the front panel (RJ-45) with two switchable to the rear transition module, the cPCI-3E12 provides two GbE ports on the front panel (RJ-45), and the cPCI-3E10-SUB provides two Fast Ethernet ports on the front panel (DB-9).
1.3 Specifications PCI Bus Architecture • • • • Bus Type: PCI Bus Width: 32- or 64-bit Bus Speed: 33/66 MHz PCI Voltage: 3.3V or 5V universal Ethernet Controller • Intel 82574L Gigabit Ethernet Controller running at PCIe 1.1 (2.5 GHz) x1 • 4x GbE ports on cPCI-3E10, 2x GbE ports on cPCI-3E12 • Data rates supported (per port): 10/100/1000 Mbps • IEEE Standard/Network Topology: 10BASE-T, 100BASE-TX, 1000BASE-T • IEEE 802.
cPCI-3E10 1.4 I/O Connectivity Table Function Model Faceplate cPCI-3E10 Y x4 cPCI-3E12 Y x2 cPCI-R3E10 Y x2 cPCI-3E10-SUB Y x2 GbE (RJ-45) Fast Ethernet (DB-9) 1.5 Block Diagrams cPCI-3E10 Block Diagram The cPCI-3E10 is based on four Intel® 82574L PCI express Gigabit Ethernet controllers. The Intel® 82574L is a highly integrated chip including Ethernet MAC and PHY. Please refer to the Intel® 82574L datasheet for more information.
cPCI-3E12 Block Diagram GbE LAN1 LAN2 Transformer GbE Intel 82574L-C PCIE x1 Intel 82574L-D PCIE x1 PEX8608 PCIE x4 PI7C9X130 J1 Figure 1-2: cPCI-3E12 Block Diagram cPCI-3E10-SUB Block Diagram LAN1 10/100 Transformer B2B Intel 82574L-C PCIE x1 Intel 82574L-D PCIE x1 PEX8608 .
cPCI-3E10 2 Board Interfaces This chapter illustrates the board layout, connector assignments, and jumper settings of the cPCI-3E10 Series. pin 2.
cPCI-3E12 Board Layout U14 U6 LAN1 U16 U3 J1 LAN2 U3 PCIe-to-PCI Bridge PI7C9X130 U6 PCIe Switch PEX8608 U14/16 Intel 82574L GbE controllers LAN1/2 GbE ports (RJ-45) J1 CompactPCI connector Figure 2-3: cPCI-3E12 Board Layout Figure 2-4: cPCI-3E12 Front Panel 6 Board Interfaces
cPCI-3E10 cPCI-3E10-SUB Board Layout LAN1 U14 U16 U6 U3 LAN2 J1 U3 PCIeto PCI Bridge PI7C9X130 U6 PCIe Switch PEX8608 U14/16 Intel 82574L GbE controllers LAN1/2 Fast Ethernet (DB-9) J1 CompactPCI connector Figure 2-5: cPCI-3E10-SUB Board Layout Figure 2-6: cPCI-3E10-SUB Front Panel Board Interfaces 7
cPCI-R3E10 RTM Board Layout J2 LAN1 LAN2 J2 CompactPCI connector LAN1/2 GbE ports (RJ-45) Figure 2-7: cPCI-R3E10 RTM Board Layout Figure 2-8: cPCI-R3E10 RTM Front Panel 8 Board Interfaces
cPCI-3E10 2.2 Connectors and Jumpers RJ-45 Ethernet Connectors On the cPCI-3E10, LAN1/2 correspond to "A/B", and LAN3/4 correspond to "C/D". On the cPCI-3E12, LAN1/2 correspond to "C/D". On the cPCI-R3E10 RTM, LAN1/2 correspond to "A/B".
LAN Routing Jumper (JP1) The cPCI-3E10 is equipped with a jumper JP1 to transfer LAN1/2 (82574L-A and 82574L-B) to J2 (RTM). See “cPCI-3E10 Board Layout” on page 5 for the location of JP1. Short pins 1 and 2 on JP1 to route LAN1/2 to the front RJ-45 connectors (default). To route LAN1/2 to J2, remove the shunt shorting pins 1 and 2 (it can be placed on either pin for storage). LAN1/2 DB-9 Connector on cPCI-3E10-SUB On the cPCI-3E10-SUB, LAN1/2 correspond to "C/D".
cPCI-3E10 CompactPCI J1 Connector Pin Z A B C 25 24 23 22 GND P5V CPCI_REQ64-L CPCI_ENUM-L P3V3 GND CPCI_AD1 P5V NC CPCI_AD0 GND P3V3 CPCI_AD4 CPCI_AD3 P5V CPCI_AD2 GND GND CPCI_AD7 GND P3V3 CPCI_AD6 CPCI_AD5 GND 21 GND P3V3 CPCI_AD9 CPCI_AD8 PCI_M66EN 20 GND CPCI_AD12 GND NC CPCI_AD11 CPCI_AD10 GND 19 GND P3V3 CPCI_AD15 CPCI_AD14 GND CPCI_AD13 GND 18 GND CPCI_SERR-L GND P3V3 CPCI_PAR CPCI_CBE-L1 GND 17 GND P3V3 IPMB_CLK IPMB_DAT GND CPCI_PER
CompactPCI J2 Connector Pin Z A B C D E F 22 GND N28342162 N28355309 N28355465 N28355622 N28346930 GND 21 GND NC GND NC NC NC GND 20 GND NC GND NC GND NC GND 19 GND GND GND NC NC NC GND 18 GND NC NC NC GND NC GND 17 GND NC GND NC NC NC GND 16 GND NC NC NC GND NC GND 15 GND NC GND NC NC NC GND 14 GND NC NC NC GND NC GND 13 GND P1V8_LANB GND NC NC P1V8_LANA GND 12 GND LANB_LED _100-L LANB_LED _1000-L LANB_LED _ACT-L G
cPCI-3E10 3 Driver Installation The cPCI-3E10 drivers are available from the ADLINK All-In-One DVD at X:\cPCI\cPCI-3E10\, or from the ADLINK website (http://www.adlinktech.com). ADLINK provides validated drivers for Windows XP and Windows Server 2003/2008. We recommend using these drivers to ensure compatibility. Driver installation is not required for Windows Vista/7 and Red Hat Enterprise Linux.
This page intentionally left blank.
cPCI-3E10 Important Safety Instructions For user safety, please read and follow all instructions, WARNINGS, CAUTIONS, and NOTES marked in this manual and on the associated equipment before handling/operating the equipment. X Read these safety instructions carefully. X Keep this user’s manual for future reference. X Read the specifications section of this manual for detailed information on the operating environment of this equipment.
X Never attempt to fix the equipment. Equipment should only be serviced by qualified personnel. A Lithium-type battery may be provided for uninterrupted, backup or emergency power. WARNING: X 16 Risk of explosion if battery is replaced with one of an incorrect type. Dispose of used batteries appropriately.
cPCI-3E10 Getting Service Contact us should you require any service or assistance. ADLINK Technology, Inc. Address: 9F, No.166 Jian Yi Road, Zhonghe District New Taipei City 235, Taiwan ᄅؑקխࡉ৬ԫሁ 166 ᇆ 9 ᑔ Tel: +886-2-8226-5877 Fax: +886-2-8226-5717 Email: service@adlinktech.com Ampro ADLINK Technology, Inc. Address: 5215 Hellyer Avenue, #110, San Jose, CA 95138, USA Tel: +1-408-360-0200 Toll Free: +1-800-966-5200 (USA only) Fax: +1-408-360-0222 Email: info@adlinktech.com ADLINK Technology (China) Co.
ADLINK Technology (Europe) GmbH Address: Nord Carree 3, 40477 Duesseldorf, Germany Tel: +49-211-495-5552 Fax: +49-211-495-5557 Email: emea@adlinktech.com ADLINK Technology, Inc. (French Liaison Office) Address: 15 rue Emile Baudot, 91300 Massy CEDEX, France Tel: +33 (0) 1 60 12 35 66 Fax: +33 (0) 1 60 12 35 66 Email: france@adlinktech.com ADLINK Technology Japan Corporation Address: ͱ101-0045 ᵅҀ䛑गҷ⬄ऎ⼲⬄䤯 ⬎ފ3-7-4 ⼲⬄ 374 ɛɳ 4F KANDA374 Bldg.
