Manual

ManualsBrandsAdvance Adapters ManualsCar50-3020A

KIT CONSISTS OF:

No. Qty Part No. Description

ADVANCE ADAPTERS INC. P/N: 50-3020A

P.O. Box 247, 4320 Aerotech Center Way New Item: (04-02)

Paso Robles, CA 93447 PAGE 1 OF 4

Telephone: (800) 350-2223 Fax: (805) 238-4201 Page Rev. Date: 02-28-14

SPECIAL NOTE: The components packaged in this kit have been assembled and machined for specific type of conversions. Modifications to any of the components will

void any possible warranty or return privileges. If you do not fully understand modifications or changes that will be required to complete your conversion, we strongly recommend

that you contact our sales department for more information. This instruction sheet is only to be used for the assembly of Advance Adapter components. We recommend that a

service manual pertaining to your vehicle be obtained for specific torque values, wiring diagrams and other related equipment. These manuals are normally available at automotive

dealerships and parts stores.

JEEP & SCOUT DANA 20 T/C TAILHOUSING

32 SPLINE OUTPUT WITHOUT YOKE

1. 1 300491 REAR YOKE END PLAY SHIM (3 sizes) (Installed by AA)

2. 1 300513 BEARING, REAR OUTPUT (YOKE SIDE) (Installed by AA)

3. 1 716303 BEARING, REAR OUTPUT (CASE SIDE) (Installed by AA)

4. 1 300625 SPEEDO RING GEAR (Installed by AA)

5. 1 300627 CIRCLIP, SPEEDO RING GEAR (Installed by AA)

6. 1 300104P SPEEDOMETER HOLE PLUG

7. 1 300629 SPEEDOMETER RETAINING CLIP

8. 1 300630 O-RING FOR SPEEDOMETER

9. 1 300922 BREATHER, BRASS ELBOW (Installed by AA)

10. 1 51-3020 CASTING (Installed by AA)

11. 1 52-3020 SHAFT (Installed by AA)

12. 1 301403 BOLT- 5/16"-18 x 3/4" H.F.C.S. SPEEDOMETER CLIP BOLT

13. 4 723730 S.H.C.S. 3/8"-16 x 1-1/4"

14. 1 723713 3/8"-16 x 1.25" STUD BOLT

15. 1 723701 3/8"-16 NUT

NOTE: This kit is 1.5" longer than stock.

THIS KIT SHOULD BE SOLD WITH A YOKE KITS THAT INCLUDES A SEAL, NUT, SAEL WASHER,

& YOKE. THIS KIT ALLOW ANY ADVANCEADAPTERS YOKE TO BE INSTALLED ON THE TAIL

SHAFT KIT.

Summary of content (4 pages)

PAGE 1
ADVANCE ADAPTERS INC. P/N: 50-3020A P.O. Box 247, 4320 Aerotech Center Way Paso Robles, CA 93447 Telephone: (800) 350-2223 Fax: (805) 238-4201 New Item: (04-02) PAGE 1 OF 4 Page Rev. Date: 02-28-14 JEEP & SCOUT DANA 20 T/C TAILHOUSING 32 SPLINE OUTPUT WITHOUT YOKE KIT CONSISTS OF: No. Qty 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15.
PAGE 2
ADVANCE ADAPTERS INC. P/N: 50-3020A P.O. Box 247, 4320 Aerotech Center Way Paso Robles, CA 93447 Telephone: (800) 350-2223 Fax: (805) 238-4201 New Item: (04/02) PAGE 2 OF 4 Page Rev. Date: 04-24-02 JEEP & SCOUT DANA 20 T/C TAILHOUSING 32 SPLINE OUTPUT WITHOUT YOKE The Dana 20 H.D. output shaft kit is a very simple kit to install. The transfer case can be left in the vehicle for the installation of this kit. Driveshaft modifications will be required due to the 1.5" longer output shaft housing.
PAGE 3
ADVANCE ADAPTERS INC. P/N: 50-3020A P.O. Box 247, 4320 Aerotech Center Way Paso Robles, CA 93447 Telephone: (800) 350-2223 Fax: (805) 238-4201 New Item: (04/02) PAGE 3 OF 4 Page Rev. Date: 06-10-09 JEEP & SCOUT DANA 20 T/C TAILHOUSING 32 SPLINE OUTPUT WITHOUT YOKE to the stud bolt has a milled pocket into which the 3/8"-16 nut must be set into. As you assemble the tailhousing to the case, thread the nut to the stud.
PAGE 4
ADVANCE ADAPTERS INC. P/N: 50-3020A P.O. Box 247, 4320 Aerotech Center Way Paso Robles, CA 93447 Telephone: (800) 350-2223 Fax: (805) 238-4201 New Item: (04-02) PAGE 4 OF 4 Page Rev. Date: 06-10-09 JEEP & SCOUT DANA 20 T/C TAILHOUSING 32 SPLINE OUTPUT WITHOUT YOKE Speedometer Calibration: There are two factors that affect your speedometer reading; actual tire diameter and axle gear ratio. The actual tire diameter is usually different than what is printed on the side wall of your tire.