HG654440 USER MANUAL EN User Manual Hob
www.aeg.com 2 CONTENTS 1. SAFETY INFORMATION...........................................................................................2 2. SAFETY INSTRUCTIONS.......................................................................................... 4 3. PRODUCT DESCRIPTION........................................................................................ 7 4. DAILY USE..................................................................................................................8 5.
ENGLISH 3 usage. Always keep the instructions in a safe and accessible location for future reference. 1.1 Children and vulnerable people safety • • • • • • • This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning the use of the appliance in a safe way and understand the hazards involved.
www.aeg.com • • • • • • • • CAUTION: The cooking process has to be supervised. A short term cooking process has to be supervised continuously. WARNING: Danger of fire: Do not store items on the cooking surfaces. Metallic objects such as knives, forks, spoons and lids should not be placed on the hob surface since they can get hot. Do not use a steam cleaner to clean the appliance.
ENGLISH • Keep the minimum distance from the other appliances and units. • Always take care when moving the appliance as it is heavy. Always use safety gloves and enclosed footwear. • Seal the cut surfaces with a sealant to prevent moisture to cause swelling. • Protect the bottom of the appliance from steam and moisture. • Do not install the appliance adjacent to a door or under a window. This prevents hot cookware to fall from the appliance when the door or the window is opened.
www.aeg.com • The information about the gas supply is on the rating plate. • This appliance is not connected to a device, which evacuates the products of combustion. Make sure to connect the appliance according to current installation regulations. Pay attention to requirements regarding adequate ventilation. 2.4 Use WARNING! Risk of injury, burns and electrical shock. • Remove all the packaging, labelling and protective film (if applicable) before first use.
ENGLISH 2.5 Care and cleaning WARNING! Do not remove the buttons, knobs or gaskets from the control panel. Water may get inside the appliance and cause damage. • Clean regularly the appliance to prevent the deterioration of the surface material. • Deactivate the appliance and let it cool down before you clean it. • Disconnect the appliance from the electrical supply before maintenance. • Do not use water spray and steam to clean the appliance. • Clean the appliance with a moist soft cloth.
www.aeg.com 4. DAILY USE WARNING! Be very careful when you use open fire in the kitchen environment. The manufacturer declines any responsibility in case of the flame misuse. WARNING! Refer to Safety chapters. 4.1 Burner overview A B C D A B C D A. B. C. D. Burner cap Burner crown Ignition candle Thermocouple 4.2 Ignition of the burner Always light the burner before you put on the cookware. 1. Push the control knob down and turn it counterclockwise to the maximum gas supply position ( ). 2.
ENGLISH If the burner accidentally goes out, turn the control knob to the off position and try to light the burner again after minimum 1 minute. stand on the Triple Crown burner only. When you refit the wok stand, make sure the recesses on the frame fit securely to the bars of the pan supports. The spark generator can start automatically when you switch on the mains, after installation or a power cut. It is normal. 4.3 Turning the burner off To put the flame out, turn the knob to the off position .
www.aeg.com Burner Diameter of cookware (mm) Burner Diameter of cookware (mm) Triple Crown 180 - 260 Semi-rapid (rear) 120 - 220 Semi-rapid (front) 120 - 180 Auxiliary 80 - 160 6. CARE AND CLEANING WARNING! Refer to Safety chapters. 6.1 General information • Clean the hob after each use. • Always use cookware with clean bottom. • Scratches or dark stains on the surface have no effect on how the hob operates. • Use a special cleaner applicable for the surface of the hob.
ENGLISH check that the burner crown holes are not obstructed. 11 conditions of the gas supply pipe and the pressure adjuster, if fitted. 6.5 Periodic maintenance Speak to your local Authorised Service Centre periodically to check the 7. TROUBLESHOOTING WARNING! Refer to Safety chapters. 7.1 What to do if... Problem Possible cause Remedy There is no spark when you The hob is not connected to try to activate the spark gen- an electrical supply or it is erator. connected incorrectly.
www.aeg.com 7.3 Labels supplied with the accessories bag Stick the adhesive labels as indicated below: A B MOD. MOD. PROD.NO. PROD.NO. SER.NO SER.NO DATA DATA C MOD. PROD.NO. SER.NO. 0049 TYPE IP20 03 IT MADE IN ITALY A. Stick it on Guarantee Card and send this part (if applicable). B. Stick it on Guarantee Card and keep this part (if applicable). C. Stick it on instruction booklet. 8. INSTALLATION WARNING! Refer to Safety chapters. 8.
ENGLISH 13 However, if the room has a door which opens directly to the outside no air vent is required even if the volume is between 5 m³ and 11 m³. If there are other fuel burning appliances in the same room, B.S. 5440 Part 2 Current Edition, should be consulted to determine the requisite air vent requirements. For appliances installed in the Republic of Ireland please refer to the NSAIDomestic Gas Installation I.S. 813 Current Editions Table Four.
www.aeg.com 8.4 Injectors replacement 1. Remove the pan supports. 2. Remove the caps and crowns of the burner. 3. With a socket spanner 7 remove the injectors and replace them with the ones which are necessary for the type of gas you use (see table in "Technical Information" chapter). 4. Assemble the parts, follow the same procedure backwards. 5. Replace the rating plate (it is near the gas supply pipe) with the one for the new type of gas supply.
ENGLISH 2. The supply system is equipped with an efficient earth connection in compliance with the current standards and regulations 3. The outlet or omnipolar switch used for connection is easily accessible with the appliance installed. The appliance is supplied with a 3 core flexible power cable with a 3 amp plug. If it is necessary to change the fuse, use a 3 amp ASTA-approved (BS 1362) fuse. A B C 15 8.
www.aeg.com 8.8 Assembly If a furniture unit is installed at a distance of 400 mm above the hob, there must be a minimum safety distance of 50 mm to the left or right from the edge of the hob. 1. 5. 2. 6. 3. min. 600 mm min. 150 mm 7. min. 650 mm min. 55 mm 30 mm 480 mm 560 mm 4. 8. 400 mm 50 mm 9.
ENGLISH 17 8.9 Possibilities for insertion A The panel installed below the hob must be easy to remove and let an easy access in case a technical assistance intervention is necessary. Kitchen unit with door or drawer B 10. A) supplied seal B) supplied brackets min 6 mm a 11. b min 30 mm min 5 mm (max 150 mm) 60 mm A. Removable panel B. Space for connections CAUTION! Install the appliance only on a worktop with flat surface.
www.aeg.com BURNER Ø BYPASS 1/100 mm Auxiliary 28 9.3 Other technical data Gas original: G20 (2H) 20 mbar = 9 kW TOTAL POWER: Gas replacement: G30 (3+) 28-30 mbar = 654 g/h G31 (3+) 37 mbar = 643 g/h Electric supply: 220-240 V ~ 50/60 Hz 3 core flexible cable with non rewireable plug fitted with a 3 amp cartridge fuse Appliance category: II2H3+ Gas connection: R 1/2" Appliance class: 3 9.
ENGLISH Energy efficiency per gas burner (EE gas burner) Left rear - Semi-rapid 56.2% Right rear - Triple Crown 52.0% Right front - Auxiliary not applicable Left front - Semi-rapid 56.2% Energy efficiency for the gas hob (EE gas hob) 19 54.8% EN 30-2-1: Domestic cooking appliances burning gas - Part 2-1 : Rational use of energy - General 10.2 Energy saving • • • • • • • Before use, make sure that the burners and pan supports are assembled correctly.
www.aeg.com 5. 6. 7. 8. for domestic purposes only, or for damage caused by a superior force (vis maior). Any repair or tampering by an unauthorised person or attempt to repair or tamper with the equipment, or use of parts not supplied by authorised agents, or alterations or modification to the equipment, shall render the warranty null and void.
ENGLISH 21 Customer Care For general enquiries or information regarding Electrolux / AEG appliances contact: Customer Care Department Electrolux South Africa (Pty) Ltd. P.O. Box 50 Paarden Eiland, 7420 Cape Town Electrolux appliances AEG appliances Telephone 00800 222 825 E-mail service@electrolux.co.za Website www.electrolux.co.za www.aeg.co.za 12. ENVIRONMENTAL CONCERNS Recycle the materials with the symbol . Put the packaging in applicable containers to recycle it.
www.aeg.
ENGLISH 23
867321958-D-352016 www.aeg.