® Since 1911 ESP Espresso Machines Instruction Manual Models: ESP1, ESP2 and ESP3 Cecilware Corporation 43-05 20th. Avenue, LIC NY 11105 Tel: 800.935.2211 / 718.932.1414 • Fax: 718.932.7860 NR27A (05/08) ® Since 1911 www.cecilware.
Operation Manual Table of Contents 1. General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . pg. 3 2. Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . pg. 4 3. Machine Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . pg. 5 4. Operations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . pg 6 5. Cleaning and Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . pg. 9 6.
1 General 1-1 This operations manual includes instructions for using and maintaining your espresso machine, please keep this manual readily available. 1-2 After unpacking, please check to ensure your machine has not been damaged during shipping and includes all parts/components. Please notify your service representative regarding any questions or concerns before installing. Please note that machine packaging material can be dangerous and should be kept out of reach of children.
1-13 Use softened water to make coffee or tea. Well / municipal water should be softened to prevent scaling in the boiler, which will shorten the serviceable life of your machine. If a hard water source is used, the filter should be replaced every two weeks -- although long-life filters may remain serviceable up to eight weeks. Actual filter replacement scheduling will vary based on volume and quality of water used. 1-14 The machine refills water automatically (see Section 4-2 for initializing).
! ! ! ! ! ! ! 3. To avoid overheating, electric wires should be kept untangled and free of obstructions. Do not block air intake or outlet vents on the machine. Never cover or otherwise prevent the free flow of air across the cup warmer. Please clean machine components with a soft cloth only. Do not use plastic or wire brushes. Turn the power off and release all boiler pressure if the machine is to remain idle for an extended period of time.
4. Operations 4-1 Activating / Deactivating the Water Inlet Motor a. If filtered water source pressure exceeds 2 bar and the amount of hot water needed is small, turn the water inlet motor (2) to the OFF (up) position to permit water inflow without internal pump assistance. b. In areas of low source water pressure, turn the water inlet motor (2) to the ON (down) position to activate the internal pump and draw water into the boiler mechanically.
c. Coffee / Tea Output Presets Place an appropriate quantity of ground coffee or tea in the filter basket and fix it into the handle seat. Choose desired water output by selecting coffee or tea output values 1 through 4. Coffee or tea flow will stop automatically. d. Continuous Output & Stop Place an appropriate quantity of ground coffee or tea into the filter basket, and fix it into the handle seat. Press the manual output button to start coffee or tea flow. Press once again to stop.
Output Volume Setup a. Turn the output volume setup switch ON (1) and press the PROG (setup) button. LED Setup Button Output Keys b. The output LEDs should be lit, indicating the machine is in setup mode. c. To configure key 1, press the key 1 button, which should light LED 1 and switch off all other LEDs. Once desired setup parameters have been set, press key 1 again to confirm and exit key 1 setup. d. At this point, LED 1 should be off and LED's 2, 3 and 4 should be lit. e.
If necessary, a mild, non-corrosive cleaning agent may be applied to the cloth. Do not spray cleaning agents directly on the machine body to avoid corrosion and possible damage to circuits. 5-2 Brewing System After each brewing cycle, remove the handle and press the manual water output button to remove all residual ground coffee from the filter element. Then, fix the handle to the seat again (Important: Do not force handle or fix it into the seat too tightly).
Dia. # 1 2 3 4 Part # 01346 01347 01348 01349 5 6 7 8 9 10 11 12 01350 01351 01352 01353 01354 01355 01356 01357 13 01358 List Description Price SILICA GEL WASHER . . . . . . . . . . . . $ 2.10 1 CUP FILTER HOLDER ASSY . . . . . 156.40 1 CUP STAINLESS STEEL FILTER . . 24.60 1 CUP FILTER HOLDER WITHOUT FILTER . . . . . . . . . . . . . . . 121.20 FILTER SUPPORT . . . . . . . . . . . . . . . 83.70 BRASS SPOUT 1 LONG CUP . . . . . . 23.40 FILTER CLAMP SPRING D1.4 . . . . . . 1.00 FILTER HOLDER KNOB CAP .
6 Trouble Shooting Indication L E Status Possible Cause Corrective Actions After two minutes of 1. Make sure that the water water input, indicator 1. Water level indicator not input switch is ON and still does not show a functioning properly. that water is flowing into rise in machine water 2. Water intake solenoid is the machine. level. It will take more out of order. Input water 2. Turn off the machine. than two minutes to flow has been Restart after 3 seconds. replenish water when interrupted. 3.
7.
Electrical Assembly Dia. Part # # 1 xxx xxx xxx 2 xxx xxx 3 xxx xxx xxx 4 xxx 5 xxx 6 01326 List Description Price MAIN SWITCH ASSY ESP1 . . . . . . . . MAIN SWITCH ASSY ESP2 . . . . . . . . MAIN SWITCH ASSY ESP3 . . . . . . . . MAIN SWITCH ESP1, 2 . . . . . . . . . . . MAIN SWITCH ESP3 . . . . . . . . . . . . . . CABLE UNIT ESP1 . . . . . . . . . . . . . . . CABLE UNIT ESP2 . . . . . . . . . . . . . . . CABLE UNIT ESP3 . . . . . . . . . . . . . . . LUMINOUS BLACK BIPOLAR . . . . . .
Water & Steam Assembly ESP1 Dia. # 1 2 3 4 5 6 7 8 Part Number xxx xxx 01334 01335 xxx 01309 xxx xxx 9 10 11 12 13 14 15 xxx 01308 01310 xxx 01311 01336 01333 Description WATER/STEAM TAP UNIT . . . . . . TAP BODY . . . . . . . . . . . . . . . . . . SEAL . . . . . . . . . . . . . . . . . . . . . . . CHROMED TAP SHAFT . . . . . . . . TAP CONNECTOR . . . . . . . . . . . . O-RING . . . . . . . . . . . . . . . . . . . . . TIGHTENING GASKET . . . . . . . . . STEAM HOT WATER A VALVE SHAFT . . . . . . . . . .
Boiler ESP 1 Hydraulic Circuit Dia. Part # # 1 xxx 2 xxx 01316 3 xxx 4 xxx 5 xxx 6 xxx 7 xxx 8 xxx 9 xxx 10 xxx 11 xxx List Description Price BOILER . . . . . . . . . . . . . . . . . . . . . . . . . . HEATING ELEMENT 1500W 110V FOR ESP1 . . . . . . . . . . . 2000W 220V FOR ESP . . . . . . . . . . . $97.40 SI-GASKET ELEMENT . . . . . . . . . . . . . . HEX SCREW (M10*16) . . . . . . . . . . . . . . SAFETY VALVE . . . . . . . . . . . . . . . . . . . . LEVEL PROBE ASSY . . . . . . . . . . . . . . .
Boiler ESP 2 Hydraulic Circuit Dia. Part # # 1 xxx 2 01315 3 xxx 4 xxx 5 xxx 6 xxx 7 xxx 8 xxx 9 xxx 10 xxx 11 xxx 12 xxx 13 xxx 14 xxx 15 xxx 16 xxx 17 xxx List Description Price BOILER . . . . . . . . . . . . . . . . . . . . . . . . . . HEATING ELEMENT 220V, 4000W . . . . .$ 118.80 SI-GASKET ELEMENT . . . . . . . . . . . . . . HEX SCREW (M10*16) . . . . . . . . . . . . . . SAFETY VALVE . . . . . . . . . . . . . . . . . . . . LEVEL PROBE ASSY . . . . . . . . . . . . . . . VALVE GASKET BRASS . . . . . . .
Boiler ESP 3 Hydraulic Circuit Dia. # 1 2 3 4 5 6 Part # xxx 01317 01318 xxx xxx 01320 7 01321 8 01319 9 01322 10 11 12 13 14 xxx xxx xxx xxx xxx 15 16 xxx xxx 17 18 19 20 xxx xxx xxx xxx List Description Price BOILER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . HEATING ELEMENT 6000W 220V . . . . . . . . $ 249.40 SI-GASKET ELEMENT FOR 220V . . . . . . . . . $ 16.00 HEX SCREW (M10*16) . . . . . . . . . . . . . . . . . SAFETY VALVE . . . . . . . . . . . . . . . . . . . . . . .
Water Level Assembly ESP1 Dia. # 1 2 3 4 5 6 7 8 9 10 11 12 Part # xxx xxx xxx 01306 xxx xxx 01307 xxx xxx xxx xxx xxx xxx List Description Price LEVEL CONNECTOR (UPPER) . . . . . . RUBBER GASKET (16*10*8) 110V MODEL . SI-O-RING (7.5*2.5) 220V MODELS . . COPPER SEAL . . . . . . . . . . . . . . . . . . $ 1.50 BRASS NUT . . . . . . . . . . . . . . . . . . . . . LEVEL-INDICATING BALL . . . . . . . . . . SIGHT GLASS FOR . . . . . . . . . . . . . . $ 9.20 SIGHT GLASS REAR COVER . . . . . . . WASHER (M8*3t) .
Distribution Group Assembly ESP 1, 2, 3 Dia. # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 Part # xxx xxx 01304 xxx 01300 xxx xxx 01301 01302 xxx xxx xxx xxx xxx xxx 01303 xxx xxx xxx xxx xxx xxx xxx xxx List Description Price DISTRIBUTION GROUP BODY . . . . . . . . . . . . . . . . . . . . CHROMED CLAMPING RING . . . . . . . . . . . . . . . . . . . . . O-RING d47*3.5t . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . $ 4.00 STAINLESS STEEL SCREW M5*10 . . . . . . . . . . . . . .
NOTES Cecilware Corporation 43-05 20th. Avenue, LIC NY 11105 Tel: 800.935.2211 / 718.932.1414 • Fax: 718.932.7860 ® Since 1911 20 www.cecilware.