User's Manual

3
Technical Support
1-800-248-0892
Ext. 2
Vehicle Type
Chevy 3500
NOTE:
For 4WD crew cab models, use driveshaft
spacer kit # 26029 (purchased seperately) in
addition to kit # 39020. If you do not already have
spacer kit # 26029, you can purchase it by calling
Air Lift’s Customer Service Department at 800-248-
0892, extension 1.
Vehicle Years
See the application guide for specifi c years.
5th Wheel Hitch
The installation of this RoadTamer kit will fi t onto most
vehicles with a fi fth wheel hitch. Some fi fth wheel
hitches may require modifi cations to make the kit fi t
properly.
See page 5 for further instructions.
Muffl er Modifi cations
Modifi cations will need to be made to the muffl er after
the completion of this kit.
Air Lift Company recommends taking your vehicle
to a muffl er repair shop upon completion of the kit
installation.
Introduction to the RoadTamer System
Vehicle Requirements
Gross Vehicle Weight Rating
(GVWR)
IMPORTANT: The installation of this kit does not
alter the GVWR or payload of the vehicle. Check
your vehicle owner’s manual and do not exceed the
maximum load listed for your vehicle.
Gross Vehicle Weight Rating - The maximum allowable
weight of the fully loaded vehicle (including passengers
and cargo). This number - along with other weight
limits, as well as tire, rim size and infl ation pressure
data - is shown on the vehicle’s Safety Compliance
Certifi cation Label.
Payload - The combined, maximum allowable weight of
cargo and pasengers that the truck is designed to carry.
It is GVWR minus the Base Curb Weight.
Air Lift Company warranties its RoadTamer
product against quality and workmanship defects
to the original retail purchaser as follows;
Main Structural components defi ned as; beams,
brackets, and links for 24 months or 24,000 miles,
whichever occurs fi rst. All other components for
12 months or 12,000 miles, whichever occurs fi rst.
Air Lift Company provides no warranty on the
vehicle’s original equipment or other aftermarket
products. This warranty does not apply to products
that have been improperly applied, installed, used
in racing applications or maintained in accordance
with installation instructions furnished with
the product. A $10.00 minimum shipping and
handling charge will apply to all warranty claims.
Before returning any defective product, you must
call Air Lift Company [phone] ext 2 for
an RGA (Returned Goods Authorization) number.
Product failures resulting from abnormal use or
misuse are excluded from this warranty. The loss
of use of the product, loss of time, inconvenience,
commercial loss, or consequential damages is
not covered. The Air Lift Company reserves the
right to change the design of any product without
assuming any obligation to modify any product
previously manufactured. Dated proof of purchase
is required.
RoadTamer Warranty and Return Policy