Owners Manual

ManualsBrandsAirQuest ManualsCooling & Air Quality110,000 BTU 80% AFUE Single Stage Multi-Positional Gas Furnace

Specifications subject to change without notice.

441 02 2401 04 5/15/18

HOME OWNER’S INFORMATION

Induced Combustion Gas Furnace

NOTE TO INSTALLER:

This manual must be left with the equipment user.

USER: Please read all instructions in the manual and

retain all manuals for future reference.

Our products are designed, tested and built in

accordance with Department of Energy (DOE)

standardized procedures; however, actual operating

results and efficiencies may vary based on manufacturing

and supplier tolerances, equipment configuration,

operating conditions and installation practices.

FIRE OR EXPLOSION HAZARD

Failure to follow safety warnings exactly could result in

serious injury, death, or property damage.

Do not store or use gasoline or other flammable vapors

and liquids in the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

−Do not try to light any appliance.

−Do not touch any electrical switch; do not use any

phone in your building.

−Leave the building immediately.

−Immediately call your gas supplier from a neighbor’s

phone. Follow the gas supplier’s instructions.

−If you cannot reach your gas supplier, call the fire

department.

Installation and service must be performed by a qualified

installer, service agency or the gas supplier.

WARNING

CARBON MONOXIDE POISONING HAZARD

Failure to follow this warning could result in personal

injury and/or death.

Carbon Monoxide is invisible, odorless, and toxic! Install

a carbon monoxide alarm in your home, even if you do

not own a gas appliance. Locate the carbon monoxide

alarm in the living area of your home and away from gas

appliances and doorways to attached garages. Follow

the alarm manufacturer’s instruction included with the

alarm.

WARNING

Use of the AHRI Certified TM Mark indicates a

manufacturer’s participation in the program. For

verification of certification for individual products,

go to www.ahridirectory.org .

Illustrations and photographs are only representative. Some product models may vary.

ELECTRICAL OPERATION HAZARD

Failure to follow this warning could result in personal

injury, death, or property damage.

Do not use this furnace if any part has been under

water. A flood−damaged furnace is extremely

dangerous. Attempts to use the furnace can result in fire

or explosion. A qualified service agency should be

contacted to inspect the furnace and to replace all gas

controls, control system parts, electrical parts that have

been wet or the furnace if deemed necessary.

WARNING

Summary of content (10 pages)

PAGE 1
HOME OWNER’S INFORMATION Induced Combustion Gas Furnace NOTE TO INSTALLER: This manual must be left with the equipment user. USER: Please read all instructions in the manual and retain all manuals for future reference.
PAGE 2
TABLE OF CONTENTS Figure 1 − 80% AFUE Single Stage Furnace Components FURNACE COMPONENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 GENERAL FURNACE SAFETY . . . . . . . . . . . . . . . . . . . . . . . . 2 IMPORTANT FACTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 SAFETY CONSIDERATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . 3 BEFORE STARTING YOUR FURNACE . . . . . . . . . . . . . . . . . 3 STARTING YOUR FURNACE . . . . . . . . . . . . . . . . . . . . .
PAGE 3
IMPORTANT FACTS (DO’S AND DON’TS) SAFETY CONSIDERATIONS S DO: READ AND UNDERSTAND THIS MANUAL. S DO: Have your furnace and vent system inspected annually by a qualified service technician. S DO: Inspect your filter monthly and clean or replace when needed. S DO: Provide adequate airflow to the furnace for efficient combustion and safe ventilation. S DO: Keep your furnace free and clear of insulating material. Some materials may be combustible.
PAGE 4
S S furnace label. If you don’t smell gas, go to the next step.” If a suspected malfunction occurs with your gas control system, such as the burners do not light when they should, refer to the shutdown procedures on inside of main furnace door, or in the “Shutting Down Your Furnace” section and call your dealer as soon as possible. Should the gas supply fail to shut off or if overheating occurs, shut off the gas valve to the furnace before shutting off electrical supply.
PAGE 5
Figure 9 − Control Switch to ON ON OFF OR A02267 8. Replace the outer door by placing flange inside casing, push door firmly against casing and turn knobs counterclockwise to tighten. Figure 10 − Furnace Door Replaced LOCK LOCK 9. Turn ON the electrical supply to the furnace. Figure 11 − Turn On Electrical Supply 11. Set the room thermostat to a temperature slightly above the room temperature. This will automatically signal the furnace to start.
PAGE 6
! Figure 13 − Turn Off Electrical Supply CAUTION CUT HAZARD Failure to follow this caution may result in personal injury. Although special care has been taken to minimize sharp edges, be extremely careful when handling parts or reaching into the furnace. Wear safety glasses, gloves, and appropriate protective clothing. FILTERING OUT TROUBLE ! A92185 CAUTION UNIT PERFORMANCE HAZARD Failure to follow this caution may result in product damage. Never operate your furnace without a filter in place.
PAGE 7
! CAUTION PERSONAL INJURY HAZARD Failure to follow this caution may result in personal injury. Use care when cutting support rods in filters to protect against flying pieces and sharp rod ends. Wear safety glasses, gloves, and appropriate protective clothing. COMBUSTION AREA AND VENT SYSTEM ! WARNING A92330 WARNING ! ELECTRICAL OPERATION HAZARD Failure to follow this warning could result in personal injury or death.
PAGE 8
BEFORE YOU REQUEST A “SERVICE CALL” Before you call for service, check for several easily solved problems: S Check for sufficient airflow. Check the air filter for dirt. Check for blocked return−air or supply−air grilles. Be sure they are open and unobstructed. If this isn’t the cause of the problem, call your servicing dealer.
PAGE 9
NOTE TO EQUIPMENT OWNER: For your convenience, please record the model and serial numbers of your new equipment in the spaces provided. This information, along with the installation data and dealer contact information will be helpful should your system require maintenance or service.
PAGE 10
Copyright 2018 International Comfort Products Lewisburg, Tennessee 37091 USA 10 Specifications subject to change without notice.