AIRSTREAM AN AMERICAN LEGEND LAND YACHT MOTORHOME OWNERS MANUAL 2005
AIRSTREAM LAND YACHT GAS OWNERS MANUAL • To place the great wide world at your doorstep for you who yearn to travel with all the comforts of home. • To provide a more satisfying, meaningful way of travel that offers complete travel independence, wherever and whenever you choose to go or stay. • To keep alive and make real an enduring promise of high adventure and faraway lands... of rediscovering old places and new interests. • To open a whole world of new experiences...
AIRSTREAM LAND YACHT GAS OWNERS MANUAL The Owners Manual for your new Airstream Motorhome is designed to respond to the most frequent inquiries regarding the operation, function and care of the many systems that make modern motor homing a joy. Airstream realizes our customers possess varying degrees of expertise in the area of repairing and maintaining the appliances in their motorhome.
AIRSTREAM LAND YACHT GAS TABLE OF CONTENTS A. WARRANTY AND SERVICE G. LP (Liquid Petroleum) Gas Water System Water Pump City Water Hookup Black Tank Flush Exterior Water Service Faucets Toilet Storage and Winterizing Drainage System Warranty Warranty Explanation Service Reporting Safety Defects Maintenance Schedule B. DRIVING Loading Weighing Safety Check List Airstream Dash Controls Motorhome Towing & Driving Tips Weighing the Motorhome C. D. F. I.
AIRSTREAM LAND YACHT GAS AIRSTREAM INC. LIMITED WARRANTY WARRANTY COVERAGE When you buy a new Airstream Land Yacht Motorhome from an authorized Airstream dealer, Airstream, Inc., warrants the motorhome from defects in material and workmanship as follows: BASIC WARRANTY PERIOD This warranty is for 30,000 miles (40,000 Kilometers) or two years, whichever comes first, beginning when the vehicle is delivered to the first retail customer or first placed into demonstrator service.
AIRSTREAM LAND YACHT GAS CARE AND MAINTENANCE This warranty covers only defective material and/or workmanship; adjustments are made at the factory prior to shipment, and rechecked by the dealer prior to delivery to the customer. Adjustments thereafter become a customer responsibility.
AIRSTREAM LAND YACHT GAS CONSEQUENTIAL AND INCIDENTAL DAMAGES Airstream, Inc., will not be responsible for any consequential or incidental expenses or damages resulting from a defect. Incidental expenses include, but are not limited to: travel expenses, gasoline, oil, lodging, meals, telephone tolls, and loss of work and loss of use of the motorhome. Some examples of consequential damages would be: stained curtains due to rain leaks or delaminated floor caused by a plumbing leak.
AIRSTREAM LAND YACHT GAS Items such as motorhome chassis, engine, tires, batteries and generator are serviced by their respective manufacturers and will be handled by their service centers according to the terms of their written policy. Any warranty forms from these manufacturers should be completed promptly, preferably at time of purchase. Your motorhome chassis is pre-checked by its manufacturer before delivery to Airstream.
AIRSTREAM LAND YACHT GAS OVERLOAD Overload Damage due to loading beyond capacity or to cause improper balance is not covered by the Airstream Limited Warranty. The Airstream motorhome body is engineered to properly handle any normal load. There are limits to the amount of load that can be safely transported depending upon speed and road conditions. If these limits have been exceeded the Airstream Limited Warranty will not cover resulting damage.
AIRSTREAM LAND YACHT GAS MAINTENANCE SCHEDULE Warning: FAILURE TO MAINTAIN YOUR COACH CAN CAUSE PREMATURE AND UNEXPECTED PARTS BREAKAGE AND/OR ERRATIC OPERATION THAT MAY BE HAZARDOUS. SERIOUS INJURY COULD RESULT FROM FAILURE TO HEED THIS WARNING. Note: See chassis and appliance manufacturer's literature for further information. EVERY 1,000 MILES OR 60 DAYS Escape Window Check operation of latches and upper hinge. Smoke Alarm Test and replace battery as required.
AIRSTREAM LAND YACHT GAS MAINTENANCE RECORDS DATE DEALER SERVICE PERFORMED A-7
AIRSTREAM LAND YACHT GAS NOTES A-8
AIRSTREAM LAND YACHT GAS DRIVING LOADING Below is a sample of the weight information chart provided in all Airstream vehicles. This information can be found in your vehicle on the back of a wardrobe door. See specification section in this manual for weights and term definitions. WEIGHT DISTRIBUTION The motorhomes have large fluid tanks and lots of storage areas. It gives you great flexibility in loading. With flexibility comes responsibility.
AIRSTREAM LAND YACHT GAS SAFETY CHECK LIST Your Airstream motorhome should be given a thorough safety check before a trip. Regular use of the following list will provide safe operation of your motorhome and will help you spot any malfunctioning equipment and correct the problem as soon as possible. The list is to help you and may not be all-inclusive. Failure to heed the following items may cause damage to the vehicle or personal injury. EXTERIOR CHECK LIST (BEFORE ENTERING VEHICLE) 1.
AIRSTREAM LAND YACHT GAS INTERIOR CHECK LIST (BEFORE DRIVING OFF) 13. Check rear view mirror adjustment, inside and outside. Adjust curtains if necessary for maximum visibility. 14. Secure children in a Federally Approved Child Restraint Device. 15. Fasten your lap belts. 16. Check that step light goes out and that electric step has retracted. SAFETY SEAT BELTS In the forward driver's area of the motorhome, safety seat belts are provided for the use of the driver and the right front passenger.
AIRSTREAM LAND YACHT GAS DASH SWITCHES • Door Lock -The main door can be locked or unlocked from the drivers seat. Remember to hide an extra door key on the exterior in case of unexpected battery failure. • Auxiliary Start - The auxiliary start switch is intended to be used if the engine battery becomes too discharged to turn the engine over. To operate, hold the switch in the start position, and then use the ignition switch in a normal fashion.
AIRSTREAM LAND YACHT GAS CAB SEATS Besides the normal power seat control there are two additional finger levers. One allows the seat to recline and the other will let the seat rotate. CAUTION: Revolving the power seat completely around will pull the wiring apart. The seats should only be swiveled toward the center of the vehicle. If the wires are loosened, following the color code can reconnect them: Red to red, green-to-green, etc. On some models the wires will be on a plug that can be reattached.
AIRSTREAM LAND YACHT GAS Procedure for Weighing A RV Vehicle should be weigh loaded as you normally travel. 1. Fill in first row from Specification Section of this manual. 2. Weigh vehicle as shown in row 2 (Scale Weight) and fill in blanks. 3. Weigh one side of vehicle as shown In Individual Wheel Position Weight. 4. Calculate other side as shown in Last Information for line 1 is located in the specification section in this manual.
AIRSTREAM LAND YACHT GAS CHASSIS The Airstream motorhome is built on a chassis designed for motorhomes. Operation of the engine and other related components is discussed in the Chassis Owners and Drivers Manual supplied with each coach. If repairs are needed it can be difficult to determine which parts are the chassis, and which are Airstream's responsibility. The following list shows the major components of the chassis and the company responsible for their servicing.
AIRSTREAM LAND YACHT GAS DASH AIR CONDITIONER/HEATER Specific Climate Systems Inc. 1200 West Risinger Road Fort Worth, Texas Technical Assistance: 1-800-275-7524 OPERATION The dash heater control is very similar to many automobiles The center rotary switch marked "cold-hot" controls the amount of hot water flowing through the heater core. When the maximum air conditioner is engaged, inside air is circulated through the evaporator to obtain the utmost in cooling.
AIRSTREAM LAND YACHT GAS C-3
AIRSTREAM LAND YACHT GAS C-4
AIRSTREAM LAND YACHT GAS C-5
AIRSTREAM LAND YACHT GAS C-6
AIRSTREAM LAND YACHT GAS AUXILIARY HEATER (Option 26 Ft.) The auxiliary heater, located under the coach near the step, is plumbed into the radiator system. Two "tees" are located between the engine and the front heater. The water lines to the heater are routed under the floor. By using the two-speed dash fan the temperature output can be varied. TIRES Your chassis Owner’s Manual contains important cautions and information on tires and should be reviewed and followed for your safety.
AIRSTREAM LAND YACHT GAS Proper FRONT END ALIGNMENT improves tire tread mileage. Your front-end suspension parts should be inspected periodically and aligned when needed. Improper alignment may not cause the vehicle to vibrate. However, improper toe alignment will cause front tires to roll at an angle, which will result in faster tire wear. Incorrect caster or camber alignment will cause your front tires to wear unevenly and can cause the vehicle to "pull" to the left or right.
AIRSTREAM LAND YACHT GAS TIRE CHANGING (cont) When removing a steel wheel rim to change a tire, loosen all wheel nuts approximately flush with end of stud, then tap clamp ring to loosen rim. Do not remove nuts until clamp rings are free or clamp ring may fly off of stud. When installing rim be sure pins on clamp ring face outboard. Then tighten attaching nuts alternately and evenly to avoid excessive wheel run-out. See torque values and sequence diagram. See tire inflation warning on page C-13.
AIRSTREAM LAND YACHT GAS TIRE ROTATION Front and rear tires perform different jobs and can wear differently depending on the types of roads driven, your driving habits, etc. To obtain the longest tire life you should INSPECT AND ROTATE your tires regularly. (See Tire Rotation Illustration below). Many automotive dealers and tire dealers will perform a free tire inspection to look for uneven or abnormal tire wear. Tires should be rotated every 6,000 to 8,000 miles.
AIRSTREAM LAND YACHT GAS TIRE SUPPORT Since motorhomes may sit for long periods of time it is important to properly support the tires if blocks are used for leveling. The following information is provided by the Michelin Technical Group. Extreme caution must be taken to ensure that the tires are fully supported when using blocks to level motorhomes and/or RV's. The load on the tire should be evenly distributed on the block and in the case of duals, evenly distributed on blocks for both tires.
AIRSTREAM LAND YACHT GAS INCORRECT One tire or a portion of one tire is supporting the full load. Portion of two tires are supporting the full load. CAUTION: Tires incorrectly supported, as shown above, may be damaged which could lead to casing failure resulting in serious injury or property damage. If, on previous occasions, the tires have been incorrectly supported, a hidden damage may be present.
AIRSTREAM LAND YACHT GAS TIRE INFLATION INFORMATION Warning: Your vehicle is equipped with a tire that is an all-steel radial. Allsteel radial tires utilize steel cords in the sidewalls, and also require increased inflation pressures. Has such, they cannot be treated like normal light truck tires. Personnel trained, supervised and equipped according to Federal Occupational Safety and Health Administration (OSHA) regulations must perform tire service, including adjusting tire pressure.
AIRSTREAM LAND YACHT GAS ELECTRIC STEP (KWIKEE STEP SERIES 28) Manufacturer: Kwikee Products Company Division of Ashton Corporation P.O. Box 638 Drain, Oregon 97435 Phone: 503-836-2126 The step is easy and convenient to operate. Just inside the main door is a wall switch for the step. When traveling, leave the switch in the "ON" position - the step will lower when the door is opened and retract when the door is closed. When parked, open the door so the step is lowered, then shut the switch off.
AIRSTREAM LAND YACHT GAS DOOR SWITCH INSTALLATION C-15
AIRSTREAM LAND YACHT GAS STEP MOTOR ASSEMBLY DIAGRAM C-16
AIRSTREAM LAND YACHT GAS MAINTENANCE AND LUBRICATION Clean all mud, salt, and road grime from step before lubricating. Lubricate all moving parts (bearings, pivot points, slides, clevis pin, and drive linkage ball) every 30 days with a good quality moisture and heat resistant penetrating grease. Kwik-Lube Spray Grease is specially formulated to lubricate Kwikee Electric Steps and is recommended for lubricating all moving parts. Refer to the figures below for lubrication locations.
AIRSTREAM LAND YACHT GAS Composite Headlamp Your new Motor Home is equipped with a composite headlamp system. Composite headlamps are designed much differently than the sealed beam units of the ’70-80s; they are a plastic lens and chrome plated reflector assembly designed around a replaceable halogen bulb. Composite lamps produce significantly greater light offering better visibility and safety for the driver.
AIRSTREAM LAND YACHT GAS Cleaning is the most effective maintenance that you can perform on your lights, dirt and road grime build up can cut light output by 40% or more. • When cleaning your headlamps, please observe the following: do not rub them dry, and never use abrasives or strong solvents. Remove dirt and contamination, such as insects, by soaking with shampoo and then rinsing with plenty of water. Always use a deicer spray to remove accumulated ice and snow; never use a scraper.
AIRSTREAM LAND YACHT GAS Replacement of the halogen bulb: • When replacing the halogen bulb do not touch the glass portion of the bulb with your bare hands since even small amounts of impurities burn into the surface and reduce the service life of the bulb. Use a clean cloth, paper napkin, or similar material to hold the bulb during installation. With most bulbs you will not need to touch the glass part to install the bulb.
AIRSTREAM LAND YACHT GAS CAMPING SAFETY: As always, safety should be one of your top priorities. Make sure you, and everyone traveling with you, can operate the main door and exit window rapidly without light. Warning: The roadside rear window is designed as an escape window. To escape, pull in on the two red latches at the bottom. The complete window sash will swing out to allow easy exit. The pleated shade is opened by sliding straight up.
AIRSTREAM LAND YACHT GAS CAUTION: BEFORE USING THE ALARM HUSH FEATURE, IDENTIFY THE SOURCE OF THE SMOKE AND BE CERTAIN A SAFE CONDITION EXISTS. FLASHING L.E.D. LIGHT: This smoke detector is equipped with a flashing red indicator light. The light is located under the test button and will flash every 30-40 seconds to indicate that the smoke detector is receiving power. TESTING: Test by pushing the test button on the cover and holding it down for a minimum of 2 seconds.
AIRSTREAM LAND YACHT GAS CLEANING YOUR DETECTOR: To clean your detector remove it from the mounting bracket as outlined in the beginning of this section. You can clean the interior of your detector (sensing chamber) by using your vacuum cleaner hose and vacuuming through the openings around the perimeter of the detector. The outside of the detector can be wiped with a damp cloth. AFTER CLEANING, REINSTALL YOUR DETECTOR. TEST YOUR DETECTOR BY USING THE TEST BUTTON.
AIRSTREAM LAND YACHT GAS WHAT TO DO WHEN THE ALARM SOUNDS: • • • • • • Leave immediately by your escape plan. Every second counts, so don't waste time getting dressed or picking up valuables. In leaving, don't open any inside door without first feeling its surface. If hot, or if you see smoke seeping through cracks, don't open that door! Instead use your alternate exit.
AIRSTREAM LAND YACHT GAS ALARM CONDITION If the COSTAR senses unsafe levels of CO, the RED L.E.D. will light up and the alarm will sound. The alarm condition will be signified by a repetitive alarm-sounding pattern of approximately 4.5 seconds on 1.5 second off. Immediate evacuation is required. Pushing the test button will silence the alarm once for approximately 4 minutes. After approximately 4 minutes the alarm will once again sound until the unsafe CO concentration is removed.
AIRSTREAM LAND YACHT GAS SERVICE AND WARRANTY If after reviewing this manual you feel that your CO Detector is defective in any way, do not tamper with the unit. Return it for servicing to: Quantum Group, Inc., 11211 Sorrento Valley Road, Suite Valley Road, Suite V. San Diego, CA 92121. Or call us toll free (800) 432-5599 E-mail address: mktsls@qginc.com LP GAS DETECTOR In the kitchen area of your unit, approximately six inches above the floor, is the LP gas detector.
AIRSTREAM LAND YACHT GAS OVERNIGHT STOP In time you will develop a knack for spotting wonderful little roadside locations by turning off the main highway and exploring. There are many modern recreational vehicle parks, including State, County and Federal parks with good facilities, where you may obtain hookups of electrical, water and sewer connections. Directories are published which describe in detail these parks and tell what is available in the way of services and hookups.
AIRSTREAM LAND YACHT GAS WINTER TRAVELING (Cont.) Some states do not allow LPG to be turned on while moving. While traveling in these states you must use your common sense. How cold is it? How long will it be before you can turn the heat back on? Is the temperature dropping or rising? Remember, the wind chill factor when driving 50 MPH will cause the interior of the motorhome to cool much faster than when it is parked. 1.You must have a plentiful supply of propane gas. 2.
AIRSTREAM LAND YACHT GAS EXTENDED STAY Making a long trip is not very different from making a weekend excursion. Since everything you need is right at hand, you are at home wherever you go. When packing for an extended trip, take everything you need, but only what you need. Some models are equipped with Hydraulic Leveling Jacks that can be deployed. Complete instructions are included with the Owners Packet. Be sure to read the directions completely prior to operating the jacks.
AIRSTREAM LAND YACHT GAS EFFECTS OF PROLONGED OCCUPANCY Your motorhome was designed primarily for recreational use and short-term occupancy. If you expect to occupy the motorhome for an extended period, be prepared to deal with condensation and the humid conditions that may be encountered.
AIRSTREAM LAND YACHT GAS TIPS TO CONTROLLING CONDENSATION (continued) The natural tendency would be to close the vehicle tightly during cold weather. This will actually compound the problem. Simply put, you need to remove some of the warm air, and allow some cool outside air to get inside the vehicle, so the furnace will not recycle the humid interior air.
AIRSTREAM LAND YACHT GAS SLIDE OUT OPERATION The slide out room on the Land Yacht Low Profile models is designed for easy deployment. A momentary switch located on the microwave cabinet operates the room. To extend or retract the room, push and release the switch. The room will slide into position and stop automatically. It is not necessary, and could be harmful to hold the switch down during room operation. To stop the room while it is in motion, push and release the switch.
AIRSTREAM LAND YACHT GAS EXTERIOR The sidewalls and roof of your Airstream Land Yacht motorhome are laminated fiberglass with a gel coat exterior finish. No paint means the small mars and scratches can be polished out or repaired using gel coat. We recommend this be done professionally since excessive polishing can remove the gel coat. There is no magic to caring for your motorhome. The finish is the same as non-painted fiberglass boats.
AIRSTREAM LAND YACHT GAS Occasionally you might find the latch catch, item 3 in the diagram below, out of time. This simply means it has been bumped and has flipped to the closed position when the door is still open. To re-time, hold the door handle in the open position, then pull out and down on the latch catch. It should flip to the open position as shown in the illustration. LOCK ASSEMBLY, DRIVERS DOOR 1. Mounting plate, Door Lock 2. Lock Handle, Inside 3. Latch Catch 4. Keeper, Rod Linkage 5.
AIRSTREAM LAND YACHT GAS KEYLESS DOOR LOCK Operation The dead bolt portion of your motorhome may be controlled by radio signals produced by the key fob shown below. One characteristic of this system is the one second delay after a pad has been depressed. NOTE: When you use the keypad to turn the patio lights ON you must also use the keypad to turn them OFF. The same goes for the switch inside the door ... if you turn the lights on with this switch, you must use the same switch to turn them off.
AIRSTREAM LAND YACHT GAS ROOF LADDER Lifting up on the bottom section of the ladder will release the hinge and allow the ladder to be pivoted down to use position. The ladder a two pins that inserted snuggly into the nylon sockets. To store, pop the ladder bottom out of the nylon sockets and fold the ladder upward at its hinge, as it nears vertical, the slot in the hinge will fall into a locked position and hold the ladder up.
AIRSTREAM LAND YACHT GAS INTERIOR The luxurious interior of your Airstream motorhome has been designed for comfort, convenience, durability and appearance. An understanding of the operational procedures and maintenance techniques of the interior appointments will add to your pleasures, as well as to the long life of your motorhome. Lounges To convert the Deluxe Sofa into a bed, pull straight up and remove armrest, grasp the front edge of the seat, raise and pull it toward the aisle of the motorhome.
AIRSTREAM LAND YACHT GAS INTERIOR (cont) Carpet The carpet can be cleaned with any good commercial carpet cleaner, or with a detergent and water. HOWEVER, BE CAREFUL NOT TO SOAK THE CARPET WITH WATER. Hardwood Flooring Daily care for the planked hardwood floor is by vacuuming. Occasionally waxing with a nonwater base wax will help extend the life of the floor. CAUTION: Warn occupants of the vehicle when fresh wax has been applied, just like a home, the floor will be slippery.
AIRSTREAM LAND YACHT GAS INTERIOR (cont) Vinyl Floor The vinyl floor in your unit can be cleaned with liquid floor cleaning solutions recommended for vinyl floors and warm water. Fabric Cleaning Warning: Keep your furniture and family safe from fires caused by careless smoking. Do not smoke when drowsy. Remove immediately any flowing ash or a lighted cigarette that falls on furniture. Smoldering smoking material can cause upholstered furniture fires.
AIRSTREAM LAND YACHT GAS Drapes Use the following procedures to remove drapery panels for cleaning Front Wrap Around Drapes 1. Remove screws securing rear end of drapery track bracket to wall, both roadside and curbside. 2. Remove the plastic end cap. 3. Slide draperies to the rear until they are clear of track. 4. After reinstalling drapes, replace the caps and refasten the track. CAUTION: All drapery materials and mattress covers must be professionally dry-cleaned.
AIRSTREAM LAND YACHT GAS PLUMBING LPG SYSTEM Your motorhome is equipped with a permanently mounted tank for LPG (Liquid Petroleum Gas). LPG burns with a clean blue flame. There are two basic types of LPG in common usage: Butane and Propane. Butane is widely used where temperatures are normally above freezing the year round, and Propane is used where subfreezing temperatures are common, since Butane freezes at 32°F as compared to -40°F for Propane.
AIRSTREAM LAND YACHT GAS BASIC RULES FOR SAFETY Warning: DO NOT store LP containers within vehicle. LP containers are equipped with safety devices that vent gas should the pressure become excessive. Warning: DO NOT use cooking appliances for comfort heating. Cooking appliances need fresh air for safe operation. Before operation open overhead vent or turn on exhaust fan and open window.
AIRSTREAM LAND YACHT GAS LP TANK INSTALLATION The regulator at the L.P. tank is under a black plastic cover. The protective cover certainly helps to keep the vent on the regulator from getting clogged by wasps or ice, but should still be checked regularly to make sure the vent remains clear. WARNING: Do not attempt to seal regulator cover. WARNING: Check vent each time tank is filled to make sure it is clear of obstructions. Gas Regulator Removal/Replacement 1. Shut off main gas supply at the tank. 2.
AIRSTREAM LAND YACHT GAS TYPICAL LP GAS SYSTEM G-4
AIRSTREAM LAND YACHT GAS WATER SYSTEM - SELF-CONTAINED The fresh water system consists of a water fill, fresh water tank, water-pump, pump filter, hot and cold water lines, water heater, drain valves, and faucets. To operate the system: Turn the water heater by-pass valves to normal flow position.
AIRSTREAM LAND YACHT GAS WATER PUMP AND STRAINER The water pump and strainer are located under the rear bed and can be accessed by opening the door at the bed footboard. The strainer should be visually checked for accumulation of sand or debris that could affect water flow. To clean the strainer screen, first remove the inlet connection from the pump side of strainer. This will allow the intake side of the strainer to be rotated about 1/8 turn counter clockwise and be removed.
AIRSTREAM LAND YACHT GAS WATER PUMP Manufacturer: Aquatec 17422 Pullman Street Irvine, CA 92614 Phone: 800-975-9995 Phone: 949-225-2200 Fax: 949-225-2222 Web site: www.aquatec.com Aquajet RV Series. This revolutionary pump employs state-of-the-art electronics to automatically control motor speed -the pump actually adjusts its speed as you open and close water fixtures.
AIRSTREAM LAND YACHT GAS ELECTRICAL: A. The Aquajet RV pump has a motor speed controller that is factory pre-set to operate at a minimum current of 10 amps while operating on a 12 VDC system. A 15-amp fuse must protect the electrical system. B. The motor speed controller has a built in heat sink. The temperature of this exposed aluminum surface may reach 200º after extended running. C. Care must be taken to insure proper connection of the positive wires (red to red), and negative black wires.
AIRSTREAM LAND YACHT GAS G-9
AIRSTREAM LAND YACHT GAS CITY WATER HOOKUP Use a high-pressure hose of at least ½ " diameter. It should be one that is tasteless, odorless and non- toxic designed for RV use. The city water inlet is a standard garden hose thread. We suggest you carry two lengths of hose. This way you have the ability to reach hookups further away than normal, plus you have a spare hose should one fail or become damaged unexpectedly.
AIRSTREAM LAND YACHT GAS EXTERIOR WATER SERVICE On the side of the 26’ and 30’ motorhomes is a large utility compartment with a keyed door. A spigot and garden hose female connector is inside. On the 33’ model in the roadside rear utility compartment on the left rear lower side is a water hose connector marked "black tank flush" and the exterior water spigot. The spigot is plumbed into the fresh water system of the motorhome.
AIRSTREAM LAND YACHT GAS PARTS DESCRIPTION 1. Solid Handle Body 2. Set Screw 3. Plug Button 4. Dome & Pivot Retainer Assembly 5. Cartridge Screw 6. Handle Adapter & Connector Assembly 7. Pivot Stop 8. Spout Retaining Nut 9. Bearing Washer 10. "D" Washer 11. Retainer Clip 12. 1225 Cartridge 13. Filter Cartridge 14. Filtering Appliance 15. Lower Spout Assembly 16. Threaded Shank 17. Supply Tubes (2) 18. Bottom Bearing Washer 19. ½ " Threaded Fitting 20. Deck Ring with Gasket 21. Deck Plate 22.
AIRSTREAM LAND YACHT GAS MICROTECH™ FILTER INSTALLATION/REPLACEMENT 1. Install a new filter by wetting the outlet ports with water and then inserting into the round filter ports on the faucet head and pushing the filter and head together. Both outlet ports must be fully inserted into the filter ports. 2. Install the filter and faucet head assembly on to the spout by wetting the faucet head o-ring seal and then carefully sliding the free end of the filter into the spout.
AIRSTREAM LAND YACHT GAS OPERATING INSTRUCTIONS Controlling The Water The PureTouch system has two options for water delivery, unfiltered stream and filtered water. STREAM MODE: Unfiltered water in regular stream flow When the water is turned on at the faucet, the spout will always begin operating in the regular stream mode. FILTERED WATER MODE: Filtered water dispensed though the separate filtered water outlet.
AIRSTREAM LAND YACHT GAS TROUBLESHOOTING PROBLEM: Water flows from both outlets, filter and unfiltered, when the filter button is pushed. SOLUTION: No filter is installed. Install a filter. PROBLEM: After installing a new filter, the filter life indicator still flashes red. SOLUTION: Filter life indicator was not reset, or the attempt to reset the indicator did not work. Perform reset sequence. PROBLEM: Reversed Hot & Cold positions, SOLUTION: HELPFUL HINTS: IT IS NOT NECESSARY TO SHUT OFF WATER SUPPLIES.
AIRSTREAM LAND YACHT GAS Moen Two Handle Lavatory Faucet Moen Model 4720 USA Moen Inc. 25300 AL Moen Dr North Olmstead, OH. 44070-8022 1-800-Buy-Moen (289-6636) Canada Moen Inc. 2816, Route Bristol, Oakville Ontario, L6H5S7 1-800-465-6130, Toronto: 905- 829-3400 Care Instructions for the Non-Tarnish Finish As with any fine polished surface, your faucet will retain its shine for years to come with proper care.
AIRSTREAM LAND YACHT GAS Typical Plumbing Diagram G-17
AIRSTREAM LAND YACHT GAS DRAIN AND HIGH PRESSURE WATER VALVES Your Land Yacht motorhome has several water line and tank drain and shut off valves. Drain Valves On the 30’ and 33’ models 3 valves are located under the double bed behind the hinged door. If you have a twin bed model, these 3 valves would be located under the curbside twin bed behind the lower access door at the front edge of the bed base. The 26’ model has 3 valves located in the roadside rear lower compartment.
AIRSTREAM LAND YACHT GAS TOILET (30’ & 33’ Models) Manufacturer: Thetford Corporation 7101 Jackson Road Ann Arbor, MI 48103 313-769-6000 Canada: Thetford Sanitation Ltd. 2710 Slough Street Mississauga, Ontario Canada, L4T 1G3 The RV toilet in your Airstream is a design that has been used for many years. In normal use, when you are hooked up to city water, both pedals are depressed together. This dumps the sewage and fresh water and flushes down the side of the bowl.
AIRSTREAM LAND YACHT GAS TROUBLE SHOOTING PROBLEM: Water keeps running into bowl. CAUSE: The blade in the bottom of the bowl is not closing completely, which in turn keeps the water control valve partially open. The groove into which the blade seats when completely closed is clogged with foreign material. REMEDY- Insert the end of a coat hanger or similar object into the sealing groove and remove the foreign material. Avoid damaging the rubber seal while cleaning. PROBLEM: Toilet leaks.
AIRSTREAM LAND YACHT GAS MAINTENANCE If the bowl-sealing blade does not operate freely after extended use, it may be restored to its original, smooth operating condition by applying a light film of silicone spray to the blade. To clean the toilet use Thetford Aqua Bowl or any other high grade, non-abrasive cleaner. Do not use highly concentrated or high acid content household cleaners. They may damage the rubber seals. REMOVAL 1. Shut off water valve behind toilet or main water supply. 2.
AIRSTREAM LAND YACHT GAS Toilet (26 Ft Model) Sealand Traveler Lite Model 111 Sealand Technology, Inc P.O. Box 38 13128 State RT. 226 Big Prairie, Ohio 44611 (800-321-9886) The Traveler toilet should be cleaned regularly for maximum sanitation and operational efficiency. You can clean that just as you would a household toilet. Do not use caustic chemicals, such as drain opening types, as they will damage the seals. BOWL CLEANING; for stubborn stains, ease Brilliance liquid or toilet bowl cleaner.
AIRSTREAM LAND YACHT GAS Sealand Toilet Traveler Lite Series 1) 344089 Seat assembly, Bone 2) 310791 Chins bowl kit, Bone 3) 310048 Ring and half clamp kit, Bone 4) 316140 Teflon® & Rubber seal kit 5) 310802 Base kit, Bone (includes 3, 4, 6, 7, 9, 10, 11, 12, 13, and 17) 6) 381162 Ball, shaft, and cartridge kit 7) 341549 Floor flange seal 8) Floor flange, see drain plumbing section of this book 9) 310064 Floor bolt mounting kit 10) 310118 Pedal cover kit 11) 314349 Water valve kit 13) 340825 Flush lever 14
AIRSTREAM LAND YACHT GAS DRAIN LINES, BELOW FLOOR 33 FOOT A. 601493 B. 601492 C. 601251 D. 601250 E. 601432 F. 600866 G. 600289 H. 601160-04 J. 601160-04 K. 601266 L 601430 Black Tank Grey Tank Bayonet Ring 0 Bayonet Cap Adapter 3 Way Elbow 3" Coupler 3" Dia x 3" 3" Dia x 10” 4 x 3 Closet Flange 3" Gate Valve 30 Ft. Drain 1. 601567 Black holding tank 2. 601492 Gray water tank 3. 601843 Dump valve assembly, rotating w/cap 4.
AIRSTREAM LAND YACHT GAS PLUMBING DRAIN WATER 26 FT 1) 601794 2) 601795 3) 601160-02 4) 601482 5) 601160-04 Gray water tank Black water tank Pipe, 1½”, ABS DVW, 4.63” long Dump valve, rotating assembly Pipe, 3”, ABS DVW, 4.63” long 453810 453981 601441 601786 Bracket, holding tank Support, holding tank System, tank flush Water fill, tank flush 914189 914196 PAN ASSY BLACK TANK PAN ASSY.
AIRSTREAM LAND YACHT GAS 33 FT.
AIRSTREAM LAND YACHT GAS 30 Above Floor Drain System G-27
AIRSTREAM LAND YACHT GAS PLUMBING DRAIN WATER 26 FT G-28
AIRSTREAM LAND YACHT GAS STORAGE AND WINTERIZING When storing your motorhome for a short or long period, use the same precautions as you would in your own home in regard to perishables, ventilation and rain protection. In addition, for prolonged storage periods flush out all the drain lines and the holding tanks. Also, drain the entire water system, including the water heater and the water storage tank. Instructions for draining the water system are explained in the following paragraphs on winterizing.
AIRSTREAM LAND YACHT GAS For additional winterizing protection, add non-toxic antifreeze (approved for drinking water systems) to your water lines using the following procedure: 1. Reconnect all lines except the hose to the pump inlet port. Close all drain valves (See Step 3) *2. Turn bypass valves to bypass position. 3. Attach a length of hose to the pump inlet port. This piece of hose should be long enough for the free end to be inserted into and reach the bottom of the antifreeze container. 4.
AIRSTREAM LAND YACHT GAS DRAIN AND WASTE SYSTEM The drain and waste system of your motorhome includes waste holding tanks made from molded plastic. The MAIN HOLDING TANK enables you to use the toilet for several days away from disposal facilities. The wastewater from the sink, shower, and bath and lavatory drain into the AUXILIARY HOLDING TANK. Each tank has its own dump valve; however, both tanks drain through a common outlet.
AIRSTREAM LAND YACHT GAS When Parked and Connected to Sewer Outlet When you are in a park and connected to a sewer outlet, keep the main holding tank dump valve closed and empty the tank every few days or whenever it becomes almost full. ONLY BY SENDING A LARGE VOLUME OF LIQUID THROUGH THE MAIN HOLDING TANK AT A TIME WILL TOILET PAPER AND OTHER SOLIDS COMPLETELY WASH AWAY. This practice will avoid the accumulation of solids in the main holding tank, which could lead to an unpleasant cleaning job.
AIRSTREAM LAND YACHT GAS ELECTRICAL SYSTEM BATTERY CONTROL CENTER The Intellitec Battery Control Center is a centralized power switching, fusing, and distribution center. Power from both the chassis and the coach batteries are feed into the control center box. All servicing with-in this box should be done only by a qualified Service Technician. Page H-3 has a drawing of the 12-volt chassis wiring system used in your motor home. Your motorhome is equipped with three batteries.
AIRSTREAM LAND YACHT GAS 12-Volt Operation The only thing you have to do is make sure the two coach batteries and engine battery does not run down. In normal usage there isn't any problem, since you would normally drive part of the day and be plugged into a campground at night. The alternator charges the batteries when you drive. When you're plugged into city power the converter charges the batteries and carries much of the load. Some nights you may not find a place to plug into city power.
AIRSTREAM LAND YACHT GAS Primary Battery Control Center Circuit Locations Front Driver’s Side Exterior Compartment H-3
AIRSTREAM LAND YACHT GAS Fuse Panel, Coach Front Roadside Exterior Compartment CIRCUIT Spare 41 1 2 4 5 COLOR Gray Purple Yellow Brown Blue MAX AMP 15 15 15 20 15 15 6 16 9 23 F-11 Red Black Green Pink Black 15 20 20 20 30 DESCRIPTION Power Awning Bedroom lights, Television, Fan Bath & vanity lights, furnace, water heater Aisle, galley, under hood, lights Bath fan, refrigerator, TV booster, RS reading lights, Fan Storage compartment lights Step, patio, dinette, and 1, 2, 3, ceiling lights Water pump,
AIRSTREAM LAND YACHT GAS H-5
AIRSTREAM LAND YACHT GAS H-6
AIRSTREAM LAND YACHT GAS EXTERIOR WORKHORSE FUSE BLOCK The 10-amp ALT/START must be a circuit breaker. Airstream functions only, see Workhorse manual for all chassis protections. NAME HORN SIZE 20A CIRCUITS PROTECTED Horn CTSY 20A Dome lights GAGES 20A See Workhorse manual AUX PWR 20A PK LPS 20A Head lamp switch TURN/BACK UP 15A Reverse view for camera. JACKS ALARM 5A CIG LTR 20A Dash 12-Volt outlet ILLUM 10A Dash switch lights RADIO-ACC 15A Monitor, Step (ign.
AIRSTREAM LAND YACHT GAS H-8
AIRSTREAM LAND YACHT GAS MONITOR PANEL Micropulse Systems Monitor CATCON PRODUCTS INC. 817-921-2188 techsupport@catconproducts.com The MicroPulse System makes use of a single solid-state sensor per tank. The MicroPulse sensor measures the static (head) pressure at the bottom of the tank and transmits this information to the MicroPulse System Monitor.
AIRSTREAM LAND YACHT GAS MICROPULSE SYSTEMS MONITOR OPERATION INSTRUCTIONS This example shows the monitor reporting the following: Fresh Water = 1/8 to Empty Gray Water 1 = Empty to 5/8 Gray Water 2 = 3/4 Black Water = Empty to 5/8 LP Gas = 1/4 Battery = Empty to 5/8 On all diagrams the Letters R=Red, Y=Yellow, G=Green, Blank=no LED lit. NORMAL OPERATION The MicroPulse Monitor will display the condition of each system at all times.
AIRSTREAM LAND YACHT GAS MICROPULSE SYSTEMS MONITOR CALIBRATION PROCEDURE STEP 1 Action: Turn the power on. Result: Display will flash all yellow 1 time, flash all green 5 times and then display all green. This confirms that the monitor is in the calibration mode. Proceed to step two. Display after completion of step one. On all diagrams the Letters R=Red, G=Green, Y=Yellow, Blank=no LED lit. STEP 2 Action: Press and release the status button one time. Result: This enters the monitor into diagnostics.
AIRSTREAM LAND YACHT GAS STEP 3 Action: Press and release the status switch 1 time. Display will light Fresh Water, Gray Water 1, Gray Water 2, Black Water, and Select Tank LED’s green. After 2 seconds, the Select Tank LED will turn off and the ready for empty LED will turn light green. Proceed to step 4. On all diagrams the Letters R=Red, Y=Yellow, Blank=no LED lit. Display after completion of step 3. On all diagrams the Letters R=Red, G=Green, Y=Yellow, Blank=no LED lit.
AIRSTREAM LAND YACHT GAS STEP 5 Action: Fill all tanks to the level that you want the monitor to report full. Maximum suggested is liquid about 1 inch below the top of the tank and the maximum is 4 inches above the empty level. When all tanks are set to the desired level press and release the status button 1 time. Result: Display will go blank for a few moments while the full values are being read.
AIRSTREAM LAND YACHT GAS TV ANTENNA Manufacturer: Winegard Company 3000 Kirkwood Street Burlington, Iowa 52601 Phone: 800-843-4741 Raising Antenna to Operating Position Turn elevating crank in "UP" direction until some resistance to turning is noted. Antenna is now in operating position. Check to make sure switch on front TV jack is on. Rotating Antenna Make sure antenna is in "UP" position.
AIRSTREAM LAND YACHT GAS Maintenance Lubrication To lubricate the elevating gear apply a liberal amount of silicone spray lubricant to the elevating gear with the lift in the down position, then run the lift up and down a few times to distribute lubricant over gears. Lubricating Rotating Gear Housing In the event that rotating the antenna becomes difficult, lubricating the bearing surface between the rotating gear housing and the base plate can restore normal operation.
AIRSTREAM LAND YACHT GAS PARTS DESCRIPTION 1. Antenna Head 2. LM-300 Leveling Mount 3. Boot, Coax Cable 4. Pin, Headed/Grooved 5. Ring, Retaining Snap 6. Spacer, Plastic 7. Grommet, Plastic 8. EG-87 Elevating Gear 9. Tube, Square Elevator 10. Elevating Shaft Assy 11. Housing, Rotating Gear 12. Ring Quad Seal 13. Bearing, Nylon 14. Housing, Base Plate 15. Bearing, Nylon 17. Plate, Ceiling 18. Screw 19. Handle, Directional 20. Spring, Handle 21. Decal, Crank Cover 22. Bearing, Nylon 23.
AIRSTREAM LAND YACHT GAS SOLAR POWER The 5 watt system installed in your motorhome primarily function is as a battery maintainer. Memory functions in radios, locks and the circuit boards in some safety devices each draw power in the milliamp range. If a charge source is not available, even these miniscule power drains will run your chassis batteries down in a few days. Barring an unusual number of cloudy days the solar system will keep your chassis batteries in pretty good condition.
AIRSTREAM LAND YACHT GAS 110-VOLT POWER The 110-volt system works very much like your home. When you're plugged into city power or start your generator, power is supplied to the 110-volt circuit breakers. The circuit breakers are located under the front of the rear bed in the 30’ & 33’ and in the top of the roadside wardrobe in the 26’. If a circuit is over loaded or a short circuit occurs, the breakers will "kick" out.
AIRSTREAM LAND YACHT GAS SWITCHOVER BOX (cont.) When you have the optional 50 amp service, the red wire shown on the following diagram will be providing power to the rear air conditioner whether you are plugged into city power or operating the generator. SWITCH OVER BOX - 50 AMP Locating Shorts and Opens The key in locating shorts and opens is isolation. The first step to isolate the circuit with the short or open. The second step is to then isolate the section of the circuit with the fault.
AIRSTREAM LAND YACHT GAS Locating Shorts and Opens (Cont.) Any damaged wire must be replaced. The National Electric Code does not permit splicing 120V wiring outside an outlet box or junction box. Also, the wire must not be exposed to an area such as a sharp metal edge that may damage the wire. OPENS 1. Check all receptacles and components for voltage on the circuit that has the open. 2.
AIRSTREAM LAND YACHT GAS 120-VOLT WIRING DIAGRAMS • 120-volt 30 amp Breaker Panel • 120-volt 50 amp Breaker Panel • Wiring Diagram, Automatic Energy Select Switch • System Layout, Automatic Energy Select Switch I-4
AIRSTREAM LAND YACHT GAS I-5
AIRSTREAM LAND YACHT GAS I-6
AIRSTREAM LAND YACHT GAS Automatic Energy Select Switch (AESS) Located in the trunk area. Front a/c is priority. Rear a/c will cool, if cool mode is selected, when front a/c has finished its cooling process. Front a/c will come back on as its thermostat detects the need to cool and the rear a/c will shut off. A/C fan (powered by 12-volt) on both units will run even if the other is cooling on the 120-volt circuit. Turn front a/c to fan or off to run rear a/c only.
AIRSTREAM LAND YACHT GAS I-8
AIRSTREAM LAND YACHT GAS NOTES I-9
AIRSTREAM LAND YACHT GAS APPLIANCES Warning: Most LP gas appliances used in recreational vehicles are vented to the outside of the vehicle. Check the exterior areas of your unit for clearance in these areas. Turn all gas operated appliances off when parked close to a gasoline pump, it is possible that gasoline fumes could enter these types of appliances and ignite from the burner flame or automatic igniters, CAUSING A FIRE OR AN EXPLOSION.
AIRSTREAM LAND YACHT GAS FURNACE (See warning at top of page J-1) Manufacturer: Hydro Flame Corporation 1874 South Pioneer Road Salt Lake City, UT 84104 Phone: 801-972-4621 The manufacturer of the furnace in your motorhome has been well known in the RV industry for many years. The furnace burns LP gas, and is powered by 12-volt current from the battery when there is no shoreline hookup or power converter when plugged into 120-volt shoreline. Operating instructions are located in your Owners Packet.
AIRSTREAM LAND YACHT GAS REFRIGERATOR (See warning at top of page J-1) Manufacturer: Dometic Sales Corporation 2320 Industrial Parkway P.O. Box 490 Elkhart, Indiana 46514 Phone: 219-295-5228 Review all Dometic Literature supplied in your Owner's Packet or stored in the refrigerator prior to operating. In an absorption refrigerant system ammonia is liquefied in the finned condenser coil at the top rear of the refrigerator.
AIRSTREAM LAND YACHT GAS RANGE Manufacturer: Magic Chef 28812 Phillips Street Elkhart, Indiana 46514 219-264-9578 People using gas ranges in their home will find little difference in the operation of the range in the motorhome. Other customers, used to electric ranges may be a little apprehensive at first; but will quickly gain confidence.
AIRSTREAM LAND YACHT GAS WATER HEATER (See warning at top of page J-1) Manufacturer: Atwood Mobile Products 4750 Hiawatha Drive P.O. Box 1205 Rockford, Illinois 61105 Phone: 815-877-7461 Note: Review the water heater literature supplied in your Owner's Packet before proceeding, Warning: Hydrogen gas can be produced in a hot water system served by this heater that has not been used for a long period of time (generally two weeks or more). Hydrogen gas is extremely flammable.
AIRSTREAM LAND YACHT GAS HIGH VOLUME ROOF VENT (OPTIONAL) Manufacturer: FAN-TASTIC VENT CORP. 4349 S. Dort Hwy. Burton, MI 48529 1-313-742-0330 1-800-521-0298 The optional high-volume roof vent system is designed to quickly exhaust stale, hot air and draw in fresh air. It's great to use when the outside temperature really doesn't call for air conditioning, but heat has built up in your coach. OPERATING INSTRUCTIONS: 1. Rotate 3-speed switch to desired position, 0-off, 1, 2, and 3.
AIRSTREAM LAND YACHT GAS AUTOMATIC SATELLITE SYSTEM (Option) The satellite system comes with an owner’s manual. The manufacturer requests that technical and warranty questions be directed to them. KING DOME SATELLITE SYSTEMS Technical Support: 1-800-982-9920 Website: www.kingcontrols.
AIRSTREAM LAND YACHT GAS SPECIFICATIONS Coach NOTE: The weights and measurements in this manual are derived from the best information available at time of this manuals publishing. Please refer to the weight information label placed in your unit and your chassis Owner’s Manual for weights specific to your RV.
AIRSTREAM LAND YACHT GAS SPECIFICATIONS NOTE: The weights and measurements in this manual are derived from the best information available at time of this manuals publishing. Please refer to the weight information label placed in your unit and your chassis Owner’s Manual for weights specific to your RV. The Unit Base Weight (UBW) and the Net Carrying Capacity (NCC) is not the same as the Unloaded Vehicle Weight (UVW) and the Cargo Carrying Capacity (CCC) shown on the Weight Information tag in your vehicle.
AIRSTREAM LAND YACHT GAS INDEX Air Conditioner.................................C-2, J-1 Alignment................................................C-8 Antenna ................................................ H-14 Appliances ............................................... J-1 Automotive Fuses................................... H-3 Auxiliary Heater ......................................C-7 Auxiliary Start Switch .............................B-4 Bathroom.................................................
AIRSTREAM LAND YACHT GAS Plumbing ................................................ G-1 Power Seats .............................................B-5 Range/Oven ..............................................J-4 Refrigerator .............................................J-3 Roof Ladder.............................................E-4 Roof Vent .................................................J-6 Safety Defects, Reporting ...................... A-5 Safety ..................................
