Owner`s manual

AJP PR4 User’s manual - 3
rd
Edition Page
35
!
WAR
N
I
NG !
- PR5 battery is sealed, it is not
necessary to check electrolyte level
therefore its covers must remain
inviolate.
- Battery electrolyte is a extremely
acid liquid and dangerous to health,
therefore it can be done no attempt
to open battery cover
- Battery will lose its charge,
approximately, if motorcycle doesn’t
run for a month;
- If motorcycle is left with no use for
long periods of time, remove battery
and charge it, to avoid sulfation and
battery lost;
- If battery is left on a unused
motorcycle, black cables must be
disconnected from battery
- Even with a regular use, after 2/3
years, battery will lose performance.
- If stabilized voltage in open circuit
is below 12.3 V, it is necessary to
recharge;
- Battery will lose performance if
charged with insufficient or
excessive current;
- During recharge some poisonous
and explosive gases may be
released;
- Always read battery recharge
instructions;
- Use an adequate 12V recharger
and follow specified recharge
method;
- After charge, battery voltage can
be recovered but if consumption is
excessive, voltage can drop quickly
or vanish. Basic cause is a defective
battery. Replace battery;
- Some electric components and
injection system may be seriously
damaged if terminals or connectors
are connected / disconnected while
ignition key is on and there is
voltage in the circuits.
- When replacing with a new battery
and if it requires filling with
electrolyte, this will produce an initial
voltage high. To ensure a maximum
performance it is necessary to
recharge battery after electrolyte
introduction, applying an initial
charge.
! WARNING !
- If electrolyte (sulphuric acid) leaks
from battery, proceed with great
care. Electrolyte can cause severe
burns.
- In case of skin contact, clear
thoroughly with water.
- In case of contact with eyes,
thoroughly apply them water for at
least 15 minutes and immediately
consult a doctor.
- Battery is a closed model but can
nevertheless emit explosive gases.
Avoid sparks and open fire near
the battery
- Defected batteries must be stored
out of reach of children. Ensure
proper disposal of discarded
batteries.
Seal battery definitely with sealing
covers strip.
Battery should be recharged out of
motorcycle, in a well ventilated space,
dry, clean and far away from any
ignition source or flammable
substances.
Charge method