SDS

ManualsBrandsAkona ManualsConcrete & Blacktop SealersRapid Patch Multi-Purpose Repair - 20 Lb.

Safety Data Sheet

Rapid Patch

Multi-Purpose Repair

Version 1.1

Page 1 of 10

TCC Materials Emergency Telephone Number: Revision Date

2025 Centre Pointe Boulevard, Suite 300 651-688-9116 June 2018

Mendota Heights, MN 55120-1221 Information Telephone Number

651-905-8137

Section 1: Product Identification

Product Type: Dry Packaged Cement-Based Products

Product Name:

Rapid Patch

Multi-Purpose Repair

Section 2: Hazard Identification

Classification of the Chemical:

Hazard Class:

This product has been evaluated according to GHS and 29CFR1910.1200, Appendix A.

Skin corrosion/irritation 2

Serious eye damage/eye irritation 1

Carcinogenicity 1A

Specific target organ toxicity - Single exposure 3 (respiratory tract

irritation)

Specific target organ toxicity - Repeated exposure 2 (lungs)

Label Elements

Hazard Pictogram:

Signal Word: DANGER.

Hazard Statement: Harmful if swallowed. The most immediate and likely hazards are

burns from dust in the eye. When the product is mixed with water, it will form an

alkaline solution, which can cause skin irritation. Dust from the product is irritating

to breathe. Prolonged overexposure to dust from the product is harmful to

breathe, because it will contain crystalline silica.

Prevention: Do not eat, drink or smoke when using this product. Wash hands

thoroughly after handling. Contaminated work clothing must not be allowed out of

the workplace. Obtain special instructions before use. Do not handle until all

safety precautions have been read and understood. Wear protective

gloves/protective clothing/eye protection/face protection. Do not breathe dust.

Summary of content (10 pages)

PAGE 2
Safety Data Sheet Rapid Patch® Multi-Purpose Repair © TCC Materials Version 1.1 Response: If swallowed: Immediately call a poison center/doctor. Rinse mouth. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a poison center/doctor. If on skin: Wash with plenty of water. Take off contaminated clothing and wash it before reuse. If skin irritation or rash occurs: Get medical advice/attention.
PAGE 3
Safety Data Sheet Rapid Patch® Multi-Purpose Repair © TCC Materials Version 1.1 Ingestion: If swallowed, do NOT induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. Get medical advice/attention. Symptoms of Overexposure, both Acute and Delayed: Eye contact: Causes serious eye damage. Eye irritation from the mechanical effect. Eye irritation, burning from cement.
PAGE 4
Safety Data Sheet Rapid Patch® Multi-Purpose Repair © TCC Materials Version 1.1 Explosion Data: Sensitivity to Mechanical Impact: Not available. Sensitivity to Static Discharge: No unusual fire or explosion hazards noted. Special Fire-Fighting Equipment and Precautions: Keep upwind of fire. Wear full fire-fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA). Do not use water jet as an extinguisher, as this will spread the fire.
PAGE 5
Safety Data Sheet Rapid Patch® Multi-Purpose Repair © TCC Materials Version 1.1 Section 8: Exposure Controls/Personal Protection Occupational Exposure Limits: OSHA PEL Portland 15 mg/m3 (T) cement 5 mg/m3 (R) Calcium Sulfoaluminate Cement Crystalline silica (quartz) 15 mg/m3 (T) 5 mg/m3 (R) 50 μg/m3 (8-hr TWA) ACGIH TLV 1 mg/m3 (R) NIOSH REL 10 mg/m3 (T) 5 mg/m3 (R) 1 mg/m3 (R) 10 mg/m3 (T) 5 mg/m3 (R) 25 μg/m3 (respirable) 50 μg/m3 (respirable) Engineering Controls: Avoid creating dust.
PAGE 6
Safety Data Sheet Rapid Patch® Multi-Purpose Repair © TCC Materials Version 1.1 Section 9: Physical and Chemical Properties Appearance: Powder. Color: Grey or grey-tan powder. Odor: No significant odor. Flash point: Noncombustible. Flammable limits: N/A Boiling Point: >2700°F Melting point: >2700°F Specific Gravity: Not available. Solubility in water: slight pH: 11-13 (cements in water) Evaporation Rate: Not applicable. Product does not evaporate.
PAGE 7
Safety Data Sheet Rapid Patch® Multi-Purpose Repair © TCC Materials Version 1.1 Skin: Causes skin irritation. May cause burns in the presence of moisture. Skin contact during hydration may slowly develop sufficient heat that may cause severe burns possibly resulting in permanent injury. Do not allow product to harden around any body part or allow continuous, prolonged contact with skin. Handling can cause dry skin. May cause sensitization by skin contact. Ingestion: Harmful if swallowed.
PAGE 8
Safety Data Sheet Rapid Patch® Multi-Purpose Repair © TCC Materials Version 1.1 Cancer (IARC) and National Toxicology Program (NTP) as a lung carcinogen. Prolonged exposure to respirable crystalline silica has been known to cause silicosis, a fibrosis (scarring) of the lungs, which may be disabling. There is evidence that exposure to respirable silica or the disease silicosis is associated with an increased incidence of Scleroderma, tuberculosis and kidney disorders.
PAGE 9
Safety Data Sheet Rapid Patch® Multi-Purpose Repair © TCC Materials Version 1.1 Do not handle until all safety precautions have been read and understood. Section 15: Regulatory Information Safety, Health, and Environmental Regulations / Legislation Specific for the Chemical Canadian: This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all the information required by the Controlled Products Regulations.
PAGE 10
Safety Data Sheet Rapid Patch® Multi-Purpose Repair © TCC Materials Version 1.1 Global Inventories Ingredient Portland cement Calcium Sulfoaluminate Cement Crystalline silica (quartz) Canada DSL/NDSL DSL DSL USA TSCA Yes. Yes. DSL Yes. Section 16: Other Information Additional information on the products is available at: www.tccmaterials.com Date of Preparation: Version: June 4, 2018 1.1 Rapid Patch® is a trademark of TCC Materials.