Manual

8.7 Checking refilling and charging the battery

Your diesel generator uses a 12V

battery for starting. Through use, the

battery may naturally lose some of its

charge along with the distilled water

inside. Before starting your generator,

periodically check for physical damage

to the battery and also the fluid levels. If

the battery is damaged, replace it. If the

fluid levels are low, fill each cell with distilled water as needed. Never use well or

tap water as they contain minerals that will harm your battery and shorten its life.

Warning:

• Batteries contain sulfuric acid which can burn your eyes and skin. Whenever

working with a battery, protect your eyes and skin from exposure to the acid.

In case of contact with any acid immediately thoroughly flush the affected

area with clean cold water and seek prompt medical attention.

• Batteries also generate hydrogen gas which can be extremely explosive. Do

not smoke or allow flames near a battery, especially while in a charging

mode. Always charge batteries in a fully ventilated area.

8.8 Inspecting the carbon brush and slip ring. Periodically, check the

generators carbon brush and slip ring and readjust if there is a spark.