PANE GENERATOR
Owner's Manual 3500W Propane Generator Limited Warranty Table of Contents Limited Wamnty 3 SafeIv Guidelines 5 General Precaulions 6 Propane Connection f8 AH-Power wananfs to the or~oinalwrchaser who uses the rrroduct in a comwner applicat~on(personal, resideitial dr household usage)that all products covered under this warranty are free from defects in materialand workmanship for one vear from the date of purchase.
Owner's ~ a n b a l 3500W Propane Generator - Limited Warranty (cont'd) Safety Guidelines Definitions TMS WARRANTY DOES NOT COVER: This manual contains important infomation that youneed to know and understandin order to protect YOUR SAFETY end to PRNENT MUIPMEM PROBLEMS. The following symbols k l p you recognize this information. Please read the manual and pay attention to these sections. Merchandise sold as reconditioned, used as rentat equipment or floor display models.
Owner's Manual 3500W Pro~aneGenerator General Recautions (cont'd) General Precautions WARNING?FAILURETO FOLLOWTHESE tNSTRimONS CANAESVlT 1N SEVERE IKItJRY OR DEATH A,.. CAUTION: FAILURETO FOLLOW THESE INSTRUCTIONSCANALSO RESULT IH DAMAGETOTHETOOL AND/OR THE IEMYO'UARE WORKINa Do not smoke, or allow sparks, flames 01 other sources of Ignitionaround the engine and fuel tank. Fuel vapon are explosive.
3500W Propane Generator Owner's Manual General Precautions (cont'd] General Precautions(cont'd] Work Area WecMcaf Safety (cont'd) * Keelp yow work area cleanandw H lit. Clutter4 benches and dark areas invite accidents A l l connectionsand condutts from the genmtor to the load must only be instelbd by trained and licensed electricians, and in compliancewithall relevant local, state, and federal electrlcal codes and standards, and ather regulations where appticable.
Owner's Manual 3500W Pro~aneGenerator General Precautions (cont'd) General Precautions (cont'd) Personal Safety {cont'd) Servicing Avoid accidentalstarting. Make sure the power switch is in its "OFF" position, and disconnect thespark pfug wire when not in use. Maintainlabels and name plates on the generator and engine. These carry imponant information. 1unreadable or missing, contact All-Power immediately for a replacement. Rmwe adjusting keys or wrenches before turning the generator on.
3500W Propane Generator Owner's Manual General Precautions (cont'd) Geneml Precautions [cont'd) Installation (cont'd) Mechanical (cont'd) If the generator is installed outdoow, it must be weatherproofed and should be soundpmofed. # should not be run outdoors without protecttonto the generator and wiring conduit. * Do not operate the generator with safety guards removed. While the generator is running, do not attempt to reach around the safety guard for maintenanceor any other reason.
Owner's Manual 3500W Propane Generator General Precautions (cont'd) Battery Extension Cord This product d o e not n e d a battery. If an extension cord (not included) is w d , make sure to use only UL approved cords having the correct gaugeand length according to the following table: Cord Lengths NameplateAmps (@ full load) 8.
Owner's Manual 3500W Pro~aneGenerator Operation Propane Connection Propane hose connection: . NOTE: f HE PARTS LISTED ABOVE ARE HELPFUL FOR LOGAnNG THE CONTROLS MENTIONEDBELOW. Rooane Cvlinder common propane BBQ eylmdm) Steo t Propane Intake Value Step 3 Insert host? connectton to generator and t~ghten. Insert other end of hose to the propane cylinder & t~ghten. Generator Propane Hose.
3500W Propane Generator Owner's Manual Operation (cont'd) C o n m l the propane hose from the bottle to the machine Turn theenglne swrtch to the 'ON' Pull the recojl starter to start the posttion englne Move the choke lever to the 'START' position Turn the fuel valve to the 'START' position Turn the fuel valve to the position Turn the valve on the propane bottle all the way open Press the "PURGE' button for 3 seconds 'RUN" Move the choke lever to the "RUN" position
Owner's Manual 3500W Pro~aneGenerator Operation (cont'd) Operation (contsd) Powering 120 Volt AC Tools And Equipment: Powering 12 VoR DC tools and Equipment: 1. Prior to powenng tools and equipment, make sure the generator's rated Wage, and amperage capacity (l20VAC B 41 AMPS)is adequate to supply all electrical loads that the unit will power. if powering exceeds the generator's capacity, R may be necessary to gmup one or more of the tools and/or equipment for connection to a separate generator. 1.
Owner's Manual 3500W Pro~aneGenerator Operation (cont'd) Spark Rug Service Inspection, Cleaning, and Maintenance A Inorder to serv~cethe spark plug, you will need a spark plug wmch {commercially availablel. Recommendedspark plugs: NHSP LO F7 RTC. To ensure proper engine opmtion, thespark plug must be propedy gapped and free of deposits. I, Flemove the spark plug cap. 2. Use a spark plug wrench to remove the spark plug. 3. Visuatly inspect the spark plug.
Owner's Manual 3500W Pro~aneGenerator Installation (cont'd) NOTE: PRIOR TO POWERING TOOLSAW0 EQUIPMENT MAKE SURE THE GEMERATOR'S RATEDVOLTAGE, WATTAGE AND AMPERAGE CAPACITY IS ADEQUATE TO SUPPLY ALL ELECTRICAL LOADS THAT THE UNIT WILL POWER. IF POWERING EXCEEDSTHE GENERATOR'S CAPACITY, IT MAY BE NECCESSARY TO GROUP ONE OR MORE OF THE TOOLS AND/OR EQUfPMENT FOR CONNECTIONTO A SEPERATE GENERATOR. Elecdncal and other permits may be requiredfor the installattonof emergency power systems.
Owner's Manual 3500W Pra~aneGenerator Compliance Specifications UNfTEP STATES ENVIRONMENTALPROTECTION AGENCY, WASHINGTON, DC 20450 2006 Model Year Certificate of Conformity Current Output Manufacturer: JlANGSU JIANGDONG GROUP GO. LTD. Small SI Engine Farnly: 6JDGS.3892LA Certificate Number: JDG-WRSI-06-06 HC+NOn FEL: g/kW-hr NIA Date 1ssued:SEP 0 8 21335 ContinuoushatedWattage MatrylrnZaw-Mon, Director. Compliance and Innovation Strategies Division,Office of Transportat~onand Air Quality.
Owner's Manual 3500W Prooane Generator Desetilption APA Parts No. ?arb Ho. Oew5lrtlon APG3535-A-01-JD JFltSB-A-01 CY LINDER HEAD COMP. APG3535-8-01-JD JF200-MI CRANK CASE APG3535-AWD JF168-A-02 IN. VALVE GUIDE APG3535-3-02-JD JF168-B-02 OIL. LEVEL SWITCH ASSY. APG3535-A-053D JF1B8-A-03 EX. VALVE GUIDE APG35358-03J D JF168-B-03 GOVERNOR GEAR ASW.
Owner's Manual 3500W Pro~aneGenerator APAParkHa. APG3535GOI-JO APG3535-GQ2-JD APG3535-C-03-JD APE3535-C-04-JD APG3535-C05-JD APG3535-G06-JD APG3535-C-07-JD APG3535-C-08-JD Pa?%No. JFf68.C-01% JF168-C-02 JFf68-C-03 JF268-C.04 JF268-B-13 JF168-C-05 JF168-C-06 JFI 68-3-1 2 DexrlptIon CRANKCASE COVER CASE COVER P OIL SCALE OIL SCALE SEAL Ol L SEAL (~25*q41.
Owner's Manual 3500W Propane Generator APAPartsWo. PertsUo. APG3535-E-01-JO JF 168-E-01 APG3535-E-OZ-JD JF200-€42 APE3535-E-03-JD JFf68-€43 APG3535-E-04-JD JF168-E-04 APG3535-E-05JD JF168-E-05 dPG3535-E-D6J D JF168-E-06 -Won PISTON RING SET PISTON PISTON PIN CONNECTING ROD ASSY. CONNECTION ROD BOLT PISTON PIN CLIP ( 18mm) A M Parts H a APG3535-F-01-.)D - .... . - APG3535-F-02-JD APG3535-F-03-3D APG3535-F-04-JD Parts No. Description APG3535-F-??-.
-- -- - . Owner's Manual 3 5 0 0 ~ ~ r o Generator ~ke APA Patts No. Parts Wo. APG3535-G-01-JD JF168-G-01 Deser-htfon RECO!~STARTER ASSY. APG3535-G-02-JD APG3535-G-03-JD APG3535-G-04-JD APG3535-G-05-JD bPG3535-G-06-JD APG3535.G-07-JD APG3535-G-08-JD APG3535-G-09-JD APG3535-G-10JD APG3535-G-11-JD APG3535-G-12-JD APG3535-G-t 3+JD SETTING SCREW RATCHET GWDE FRICTION SPRING STARTER RATCHET RATCHET SPRING RECOIL STARTER 'REEL RECOIL STARTER SPRING RECOtL STARTER CASE 60MP.
3500W Propane Generator APA Parts No, dPG35354-0140 APG3535-I-02-JD APG3535-1.03-JD APG3535-I+W-JD APG3535-I-05JD APG3535-1-06J O APG3535-I-07-JD APG3535-I-08JD APG3535-I-09JD APG3535-I-f 0-JD APG3535-1-1I-JD APG3535-I-12-JD APG3535.I-13-JD Parts No.
Owner's Manual AWRarts No. Parts Wo. APG3535-K-01JD J132000-A-O;1 ~ ~ ~ 3 5 3 5 - K - 0 2JD2000-A-02 :~~ Desaiptlon FLANGE BOLT (M6*12) MUFFLER PRQTECTOR .ID7000-A-03 - -- .. .. FLANGE BOLT --- - lM8~251 - --, APG3535-K.03-.1D - .- - . ..- - APG3535-K-044D JD2000-A-04 bPG3535-K-05-JD J132000-A-05-- # EXHAUST PIPE EXHAUST PIPE NDT (Me) -- - -~ ~ ~ 3 5 3 5 - ~ - 0 6 - ~ ~ - ~ 0 2 0 0 0 - ~ - 0EXHAUST 6 PIPE GASKET---APG3535-K-07-JD JD3500tPG-A-01 MUFFLER COMP.
Owner's Manual 3500W Pro~aneGenerator APA Parts H a APG3535-M-0140 APG3535-M42*JO APG3535-M-0340 APG3535-M-04-JD APG5535-M-05-JD APG3535-M-06-JD APG3535-M-07JD APG3535*M*08JD Parts Na JF168-P-18 JF168-P-06 JF168-P-19 JF168-P-04 JF168-P-25 JF168-P-07 JF168-P-05 JF188-P-08 Oestridion FLANGE BOLT w8xT2) GOVERNOR SPRING FLANGE BOLT (M6) CONTROLARM FLANGE NUT (ME) THROTTLE RETURN SPRING GOVERNOR ROD CONTROL ASSY APAPartsNa APG3535-N-01JD APG3535-N-0240 APG3535-N-03JD - Park*.
Owner's Manual 3500W Pro~aneGenerator APAPartsUo. APG3535-0-07 J D APG3535-0-02-JD APG3535-0-03-JD APG3535-0-04-JD APG3535-0-05-JD APG3535-0-06-JD APG3555-0-07-JD bPG3535-0-08-JD PwbNo. J035QOLPG-C-Of JD3000-0-02 JD3000-B-03 JD3500tPG-C-02 JD3500LPG-C-03 JD3500LPG-C-04 JD3500LPG-GO5 JD3500LPG-C-06 FRAME COMP. BOTTOM RUBBER FLANGE NUT (MI) ARC COVER FLANGE BOLT (M6X12) FLANGE NUT (M6) COPtNG FIX FRAME APA Parts No. Parts No.
