Use and Care Manual

ManualsBrandsAll Power ManualsOutdoor Power Equipment3200 psi 7 HP Pressure Washer

5120

Pressure Washer

Important Safety Instructions

WARNING – When using this product basic precautions should always be followed,

including the following:

1. Read all the instructions before using the product.

2. To reduce the risk of injury, close supervision is necessary when a product is

used near children.

3. Know how to stop the product and bleed pressures quickly. Be thoroughly

familiar with the controls.

4. Stay alert – watch what you are doing.

5. Do not operate the product when fatigued or under the influence of alcohol or

drugs.

6. Keep operating area clear of all persons

7. Do not overreach or stand on unstable support. Keep good footing and balance

at all times.

8. Follow the maintenance instructions specified in the manual.

“WARNING – Risk of Injection or Injury– Do Not Direct Discharge Stream At

Persons.”

1. “WARNING: If you do not follow these instructions exactly, a fire or explosion

may result causing property damage, personal injury or loss of life.”

2. “In the event of pilot outage, wait at least five minutes to clear out any gas before

relighting.”

3. “Use only your hand to push in or turn the gas control knob. Never use a tool. If

the knob will not push in or turn by hand, don’t try to repair it; call a qualified service

technician.”

Summary of content (13 pages)

PAGE 1
5120 Pressure Washer Important Safety Instructions WARNING – When using this product basic precautions should always be followed, including the following: 1. Read all the instructions before using the product. 2. To reduce the risk of injury, close supervision is necessary when a product is used near children. 3. Know how to stop the product and bleed pressures quickly. Be thoroughly familiar with the controls. 4. Stay alert – watch what you are doing. 5.
PAGE 2
Pressure Washer Owner’s Manual Table of Contents Warning! Read And Understand All Safety Precautions In This Manual Before Operating. Failure To Comply With Instructions In This Manual Could Result In Personal Injury, Property Damage, And / Or Voiding Of Your Warranty. All Power America Will Not Be Liable For Any Damage Because Of Failure To Follow These Instructions.
PAGE 3
Owner’s Manual Owner’s Manual Pressure Washer General Precautions (cont’d) The following safety precautions apply whenever using, storing, or servicing your pressure washer to reduce the possibility of personal injury. Overlooking or ignoring these precautions can lead to personal injury or product damage. • Keep the pressure washer clean and free of oil, mud and other foreign matter. • Do not wear loose clothing, jewelry, or anything that may be caught in the engine.
PAGE 4
Owner’s Manual Owner’s Manual General Precautions (cont’d) Before Operation • Do not touch hot muffler. NOTE: The engine and pump on your pressure washer will often have improved performance after a break-in period of several hours. • Service, operate and refuel under the following conditions: a. Good ventilation b. Refuel the pressure washer in a well lit area. c. Avoid fuel spills and never refuel while the pressure washer is running. d. Avoid any ignition source when refueling. e.
PAGE 5
PAGE 6
PAGE 7
Owner’s Manual Owner’s Manual Maintenance Maintenance 2. Clear the nozzle with a small rigid piece of wire such as a paper clip. 3. Flush the nozzle backwards with water. 4. Reconnect the wand to the gun. Restart the pressure washer and depress the trigger on the spray gun. If the nozzle is still plugged or partially plugged, repeat above instructions 1-4. If the previous procedure does not clear the nozzle, replace with a new nozzle.
PAGE 8
Owner’s Manual Trouble Shooting Owner’s Manual Trouble Shooting • Engine wil not start or stops while operating.
PAGE 9
Owner’s Manual Limited Warranty Owner’s Manual Limited Warranty (cont’d) All-Power America warrants to the original purchaser who uses the product in a consumer application (personal, residential or household usage) that all products covered under this warranty are free from defects in material and workmanship for one year from the date of purchase. All products covered by this limited warranty which are used in commercial applications (i.e.
PAGE 10
NO APA Parts NO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 APW5120-YG-01 APW5120-YG-02 APW5120-YG-03 APW5120-YG-04 APW5120-YG-05 APW5120-YG-06 APW5120-YG-07 APW5120-YG-08 APW5120-YG-09 APW5120-YG-10 APW5120-YG-11 APW5120-YG-12 APW5120-YG-13 APW5120-YG-14 APW5120-YG-15 APW5120-YG-16 APW5120-YG-17 APW5120-YG-18 APW5120-YG-19 APW5120-YG-20 APW5120-YG-21 APW5120-YG-22 APW5120-YG-23 APW5120-YG-24 APW5120-YG-25 APW5120-YG-26 APW5120-YG-27 APW512
PAGE 11
Owner’s Manual NO APA Parts NO 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 APW5120-YG-41 APW5120-YG-42 APW5120-YG-43 APW5120-YG-44 APW5120-YG-45 APW5120-YG-46 APW5120-YG-47 APW5120-YG-48 APW5120-YG-49 APW5120-YG-50 APW5120-YG-51 APW5120-YG-52 APW5120-YG-53 APW5120-YG-54 APW5120-YG-55 APW5120-YG-56 APW5120-YG-57 APW5120-YG-58 APW5120-YG-59 APW5120-YG-60 APW5120-YG-61 APW5120-YG-62 APW5120-YG-63 APW5120-YG-64 APW5120-YG-65 APW5120-YG-66 APW51
PAGE 12
Owner’s Manual Owner’s Manual NO. APA Parts No. DESCRIPTION NO. APA Parts No. DESCRIPTION 1 APW5120-P-01 Overflow valve 37 APW5120-P-37 non-returnedvalve spring 2 APW5120-P-02 Nut M5 38 APW5120-P-38 copper cover 3 APW5120-P-03 Adjusting pressure nut 39 APW5120-P-39 venturi tube 4 APW5120-P-04 adjusting pressure spring 40 APW5120-P-40 O ring 9.3*1.
PAGE 13