User guide

ManualsBrandsAllen Sports ManualsFor bicyclesSST1

INSTRUCTIONAL

OWNER’S MANUAL

MODEL SST1 JOGGER/BIKE TRAILER

Owner’s Manual should be kept for future reference

WARNING

1. Completely read and understand Owner’s Manual before assembling or operating this product.

2. This product should be assembled by an adult

SAFETY TOWING TIPS

IMPORTANT SAFETY INFORMATION

WARNING #1:

• Failuretofollowthesewarningsandassemblyinstructionscouldresultinseriousinjuryordeath!

 • Immediatelydiscardallplasticbagsandplasticwrappingmaterials!

 • Maximumweightcapacityforthistrailerisone(1)childat50pounds,maxpayload!

 • Neverusethistrailer/strollerifitbecomesdamaged!

 • Toavoidseriousinjury,childrenshouldalwaysweartheseatbeltandtheshoulderstraps!

 • Donotinstallacarseatoranyotherseatingdevicenotapprovedbythemanufacturerinsidethetrailer!

 • AreectorthatcomplieswithCPSCregulationsmustbevisibleontherearoftrailer.

 • Neverleavechildrenunattendedinoraroundthisproduct!

 • Neverallowchildrentoassemble,fold,ordisassemblethisunit!

 • Accessoriesorparcelsplacedintrailer/strollermaycauseittobecomeunstable!

 • Notforusewithchildrenunder12monthsold!Childrenmustbeabletosupporttheirownheads!

 • Beforeriding,checkthatallpartsareassembledaccordingtothemanufacturerinstructions!

  Also,ensurethatthetrailerdoesnotinterferewithbraking,pedaling,orsteeringofthebicycle!

 • Donotallowanyofthechild’sbody,clothing,shoelaces,ortoystocomeintocontactwithmovingparts!

 • Makenomodicationstothetrailer!

 • Tiresshouldbeinatedto25-35PSIformaximumcomfort!Checktirepressurebeforeeachuse!

 • Useafootpumporhandpumptoinatetires!Pressurizedairhosescancauseoverination!

 • Periodicallyre-checkallfastenerstomakesuretheyaretight!

 • Cleantraileronlywithsoapandwater.Donotusesolvents!

TOWING TIPS:

 • Makesureyourbikebrakesworkproperly!Brakingdistanceisincreasedwhenpullingatrailer!

 • Thistraileriswide!Allowextraclearancenearcurbs,signs,parkedcars,andotherobstacles!

 • Abicyclewithtrailerattachedrequiresawideturningradius!Donotturnsharply!

 • Childrenmustwearanapprovedsafetyhelmetwhenusingthisproductintrailermode!

 • Neverremoveprotectivecanopywhenpullingchildreninthetrailer!

 • Alwaysusethesafetyagwhenpullingthistrailer!

 • Donotrideovercurbs!Avoidbumpsandholes!Alwayssignalyourturns!

 • Useextracautionwhenturningonunevenpavement,andgoingdownhill!

 • Notforuseathighspeeds!Donotexceed10MPH!

 • NEVERusethistraileratnight!

 • Installarearviewmirroronyourbiketocheckonchildrenintrailer!

 • Dresschildrenappropriatelytopreventthemfromgettingchilledoroverheatedwhileriding!

  Protectagainstwind-chillincoldtemperatures,andprovideadequateventilationandhydrationduring

  warmertemperatures.

Summary of content (10 pages)

PAGE 1
INSTRUCTIONAL OWNER’S MANUAL 1 p MODEL SST1 JOGGER/BIKE TRAILER Owner’s Manual should be kept for future reference 1. Completely read and understand Owner’s Manual before assembling or operating this product. 2.
PAGE 2
INSTRUCTIONAL OWNER’S MANUAL FULLY ASSEMBLED JOGGER PARTS LIST QUANTITY 2 p DESCRIPTION 1 Frame w/ Canopy, Sling Seat with 5 point safety harness, tow bar, tow bar coupler and rear wheel bracket attached 2 16” Rear wheels 1 Safety flag 1 Jogger front fork 1 12” Quick Release front wheel 1 Jogger handlebar with wrist strap
PAGE 3
INSTRUCTIONAL OWNER’S MANUAL TRAILER ASSEMBLY & OPERATING INSTRUCTIONS STEP 1: NOTE(S): 3 p Remove the trailer from the box and check contents against the parts list. 1. Lay the trailer on the ground with the black fabric side down. 2. Do not remove the white foam from the wheel axles until STEP 4 FIGURE 1. WARNING!: IMMEDIATELY DISCARD ALL PLASTIC BAGS AND WHEEL WRAPPING MATERIALS! STEP 2: OPEN FRAME Remove trailer and all components from carton.
PAGE 4
INSTRUCTIONAL OWNER’S MANUAL WHEEL INSTALLATION WARNING! 4 p Remove the foam from the wheel axles and discard immediately. Do not remove washers. STEP 1: Lift the trailer back so the right side is up, and locate the right wheel. STEP 2: Install the wheel axle by sliding the axle completely through the bracket in the frame as shown. STEP 3: Insert the Quick Release Pin (tethered to the trailer frame near the wheel bracket) through the hole in the axle and lock the clip to secure the pin.
PAGE 5
INSTRUCTIONAL OWNER’S MANUAL SAFETY FLAG INSTALLATION STEP 1: Assemble the flag and insert the end into the small sleeve on the side of the trailer skin. Reattach the Velcro to secure the cover. NOTE: Flag should be removed before attempting to fold trailer WARNING!: This flag is meant for use only with the trailer. This flag is not a toy. Do not let your child play with this flag at any time. Failure to comply with this warning could result in serious injury of your child.
PAGE 6
INSTRUCTIONAL OWNER’S MANUAL 6 p SECURING CHILD WITH 5-POINT SAFETY HARNESS WARNING! To avoid serious injury, children should always wear the seat belt, shoulder strap, and a helmet! STEP 1: Undo the lap belt buckle and seat the child in the CENTER of the trailer. Buckle the lap belt [A] over the child’s lap, and pull the strap until the belt is tight. STEP 2: Place the two center shoulder straps [C] over the child’s shoulders, and clip both straps into “D” Ring [D] of the center crotch strap.
PAGE 7
INSTRUCTIONAL OWNER’S MANUAL FOLDING FOR STORAGE AND TRANSPORT STEP 1: 7 p Remove children and all cargo from inside the passenger compartment. STEP 2: Unclip the tow bar safety strap from the “D” ring, and remove pin to remove hitch from frame. STEP 3: Clip the end of the strap back on to the tow bar “D” ring. STEP 4: Remove the flag and pole and separate the three sections. STEP 5: Remove the quick-release pins form the stub axles of the rear wheels.
PAGE 8
INSTRUCTIONAL OWNER’S MANUAL INSTALLING THE FRONT FORK NOTE: 8 p The Jogger Kit includes : Front fork Front wheel Handlebar FIGURE 25. NOTE: Remove QR pins from hitch arm, and fold hitch arm back to folded away position(Fig 26). Refit the QR pin to fix the hitch arm (Fig 27). Remove the QR pin from the right side receiver to make way for fork installation. FIGURE 26. STEP 1: FIGURE 27.
PAGE 9
INSTRUCTIONAL OWNER’S MANUAL INSTALLING JOGGER WHEEL NOTE: IMPORTANT: PLEASE FOLLOW INSTRUCTIONS FOR QUICK RELEASE LEVER The Jogging Stroller is equipped with a Quick Release front wheel. Place the Stroller so the rear wheels and handle are touching the floor. STEP 1: The front axle has a flat area on it that you must align with the slots in the front fork (Fig 32). STEP 2: After aligning the front wheel in the fork slots, slide the wheel all the way into the front fork (Fig 33). 9 p FIGURE 32.
PAGE 10
INSTRUCTIONAL OWNER’S MANUAL INSTALLING JOGGER HANDLEBAR NOTE: 10 p The handlebar attaches to the rear of the trailer frame with clamps, secured with large hand knobs. To install, first loosen the hand knobs to open the clamps sufficiently to fit over the frame, Position the handlebar at a comfortable height, and retighten the hand knobs. Reattach the top cover before use. The cover has cutouts to allow use with the handlebar in place. FIGURE 36.