Specifications

COMBITHERM GAS INSTALLATION AND MAINTENANCE MANUAL — 6011ML
PG.18
2.2 Preventive Maintenance
In addition to the routine cleaning and maintenance procedures, there are several additional steps to be
taken for both sanitation purposes and to keep the oven running at top operating efficiency. These
additional safeguards will help prevent inconvenient down time and costly repairs.
●
DO NOT DISPOSE OF GREASE, FAT, OR SOLID WASTE DOWN THE OVEN DRAIN. Fats and
solids will eventually coagulate in the drain system, causing blockage.
●
MAKE CERTAIN THE DRAIN SCREEN IS ALWAYS IN PLACE. REMOVE ANY SOLID WASTE
MATERIAL FROM THE DRAIN SCREEN BEFORE IT ENTERS THE DRAIN SYSTEM. The routine
removal of solids from the drain screen will help prevent blockage.
●
USE THE AUTHORIZED COMBITHERM OVEN CLEANER ONLY. The use of unauthorized
cleaning agents may discolor or harm the interior surfaces of the oven.
●
TO PROLONG THE LIFE OF THE DOOR GASKET, REMOVE AND CLEAN THIS ITEM DAILY. The
acids and related compounds found in fat, particularly chicken fat, will weaken the composition
of the gasket unless cleaned on a daily basis.
●
TO ADDITIONALLY PROTECT GASKET LIFE, ALLOW OVEN DOOR TO REMAIN SLIGHTLY
OPEN AT THE END OF THE PRODUCTION DAY. An open door will relieve the pressure on the
door gasket.
●
ROUTINELY CLEAN DOOR HINGES. Open oven door to relieve tension. Clean all parts of the hinge.
2.3 Routine Cleaning Requirements
DAILY OVEN CLEANING
To be performed at the end of each production day or between production shifts.
MONTHLY CLEANING
WATER INTAKE FILTER CLEANING
CLEANING THE DRAIN PIPE
CLEANING THE FLUE OUTLET
FAN CLEANING
DAILY GASKET CLEANING
It is important to prolong the life of the oven gasket by cleaning this item on a daily basis. Routine cleaning
will help protect the composition of the gasket from deterioration caused by acidic foods. After allowing the
oven to cool, remove pull-out gasket and wash in hot, soapy water. Do not place in the dishwasher.
COMBITHERM® CLEANING & MAINTENANCE
Always replace the gasket before cleaning the oven interior or operating the oven.