User Guide

#472 - 1/08 D U E T O O N G O I N G P R O D U C T I M P R O V E M E N T, S P E C I F I C AT I O N S A R E S U B J E C T T O C H A N G E W I T H O U T N O T I C E . www.alto-shaam.com
G A S C O M B I N AT I O N OV E N / S T E A M E R 7

14ESG
C A PA C I T Y
FULL-SIZE PANS: 20" x 12" x 2-1/2" Fourteen (14) Twelve (12)
GN 1/1: 530 x 325 x 65mm Fourteen (14) Twelve (12)
GN 2/1: 650 x 530 x 65mm Seven (7) Five (5)
FULL-SIZE SHEET PANS:* 18" x 26" x 1" Seven (7) Six (6)
ON WIRE SHELVES ONLY
168 lb (76 kg) MAXIMUM
VOLUME MAXIMUM
: 105 QUARTS (133 LITERS)
W E I G H T
NET NOT YET AVAILAB LE
SHIP NOT YET AVAILAB LE
CRATE
48" X 56" X 50" EST.
DIMENSIONS: (1219 x 1422 x 1473mm)
E L E C T R I C A L 7 • 1 4 E S G 7 • 1 4 E S G / s k
VOLTAGE PHASE CYCLE/HZ AWG AMPS kW AMPS kW
110 - 120 1 50/60 2 Wire plus ground, AWG 12 5.7 0.68 9.5 1.14
OTH ER VOLTAGES AVA IL ABLE : Range 200 — 415V — 1 or 3 ph, 50 or 60 Hz
Water Drain
(Bottom)
25-5/8"
(650mm)
9
/16"
(
13mm)
8
-1/2" (216mm)
42" (1066mm)
4-13/16"
(121mm)
3
1-3/4"
(
805mm)
3
3-1/8"
(840mm)
7-3/16"
(
181mm)
73-7/16" (1865mm)
37-5/8” (954mm)
30-1/16"
(763mm)
4-5/8" (116mm)
2" (50mm)
47-7/8" (1215mm)
2
2-11/16"
(
575mm)
49-13/16" (1265mm)
4
1-3/4" (1060mm)
44-7/16" (1128mm)
5
5-1/16" (1398mm)
W
ater Drain
(
Side Back)
2
7-9/16"
(
700mm)
3
-9/16"
(
89mm)
4
-3/8" (110mm)
6”
(151mm)
17-3/8"
(441mm)
19-3/8"
(491mm)
26-3/4"
(678mm)
S
team Vent (Top)
Gas Connection
(
Bottom)
Treated Water Intake (Bottom)
U
ntreated Water Intake (Bottom)
Electrical
C
onnection (Bottom)
7
-9/16"
12-13/16"
(325mm)
(192mm)
D I M E N S I O N S : H x W x D
EXTERIOR:
42" x 49-13/16" x 44-7/16" (1066mm x 1265mm x 1128mm)
EXTERIOR WITH RETRACTABLE DOOR:
42" x 53-13/16" x 44-7/16" (1066mm x 1367mm x 1128mm)
I
NTERIOR
:
23-5/8" x 25-1/4" x 33-7/8" (600mm x 640mm x 860mm)
*ADDITIONAL WIRE SHELVES REQUIRED FOR MAXIMUM CAPACITY
C L E A R A N C E R E Q U I R E M E N T S
LEF T: 6" (152mm) PLUS SERVI CE ACCESS: 18" (457mm) RECOMMEND ED
20" (508mm) F R O M H E AT P R O D U C I N G E Q U I P M E N T
RIG HT
: 4" (102mm) TOP : 20" (508mm) FOR AIR MOVEMENT
BAC K
: 4" (102mm) BOTT OM: 5-1/8" (130mm) FOR LEGS
COUNTER
-TOP INSTALLATIONS MUST MAINTAIN 4" (102mm)
MINIMUM CLEARANCE FROM THE COUNTER SURFACE.
G A S R E Q U I R E M E N T S
C
ONNECTED ENERGY LOAD
: 91,000 Btu/hr
HOOK-UP: 3/4" NPT
MINIMUM CONNECTED PRESSURE: 5.5" W.C. (Natural Gas)
9" W.C. (Propane)
MAXIMUM CONNECTED PRESSURE: 14" W.C.
GAS TYPE MUST BE SPECIFIED ON ORDER.
WAT E R R E Q U I R E M E N T S
TWO (2) COLD WATER INLETS - DRINKING QUALITY
ONE (1) TREATED WATER INLET: 3/4" NPT
ONE (1) UNTREATED WATER INLET: 3/4" NPT
LINE PRESSURE: 30 to 90 psi 2.8 to 6.2 bar
WATER DRAIN: 1-1/2"
FERNCO CONNECTION WITH AIR GAP
I N S TA L L AT I O N R E Q U I R E M E N T S
Oven must be installed level. Hood installation. Water supply
shut-off valve and back-flow preventer. Alternate burner orifice
is required for installation sites at elevations of 3,000 feet (914m)
above sea level.
WAT E R Q U A L I T Y M I N I M U M S TA N D A R D S
USING A WATER SUPPLY NOT MEETING ALTO-SHAAM'S
MINIMUM WATER QUALITY STANDARDS WILL VOID THIS
WARRANTY. It is the responsibility of the purchaser to ensure
that incoming water supply is compliant with the specifications
listed through adequate treatment measures. Installation of the
CombiGuard™ Water Filtration System is recommended, but this
system may not address all water quality issues present.
Contaminant Inlet Water Requirements (untreated water)
Free Chlorine Less than 0.1 ppm (mg/L)
Hardness Less than 3 gpg (52 ppm)
Chloride Less than 30 ppm (mg/L)
pH 7.0 to 8.5
Alkalinity Less than 50 ppm (mg/L)
Silica Less than 12 ppm (mg/L)
Total Dissolved
Solids (tds) Less than 60 ppm