Use & care guide

10
INSTALLATION INSTRUCTIONS
Gas Connection Requirements
Explosion Hazard
Do not store fuel tank in a garage or indoors.
Do not store grill with fuel tank in a garage or
indoors.
Failure to follow these instructions can result in
death, explosion, or re.
LP Gas:
IMPORTANT: A 20 lb LP gas fuel tank must be purchased
separately.
IMPORTANT: The gas pressure regulator/hose assembly
supplied with the grill must be used. Replacement gas
pressure regulator/hose assembly specic to your model,
is available from your outdoor grill dealer.
To Install the 20 lb LP Gas Fuel Tank:
Set tank in hole in the cart base.1.
Screw the gas pressure regulator/hose assembly on to the 2.
20 lb LP gas fuel tank as shown
Place the 20 lb LP gas fuel tank secure ring over the collar of 3.
the tank as shown.
A
A. Gas pressure regulator/hose assembly
NOTE: The 20 lb LP gas fuel tank orientation shown in
the illustration above must be followed to provide proper
vapor withdrawal.
Turn on the gas supply. Wait a few minutes for gas to move 4.
through the gas line.
Test all connections by brushing on an approved 5.
noncorrosive leak detection solution. Bubbles will
show a leak. Correct any leak found.
Check the Burners
The burners are tested and factory-set for most efcient
operation. However, variations in gas supply and other
conditions may make minor adjustments to air shutter or low
ame setting necessary.
It is recommended that a qualied person make burner
adjustments.
Checking the grill burner ames requires removing the grate
and avor grids.
Burner Flame Characteristics
The ames of the grill burners and side burners (on some
models) should be blue and stable with no excessive noise
or lifting (LP gas ames will have a slightly yellow tip). A yellow
ame indicates not enough air. If ame is noisy or lifts away
from the burner, there is too much air. Some yellow tips on
ames when the burner is set to HI setting are acceptable
as long as no carbon or soot deposits appear.
Check that burners are not blocked by dirt, debris, insect nests
etc. and clean as necessary.