Manualshelf

User Manual

ManualsBrandsAmerican Car Craft ManualsFor the carChrysler 300 _ Dodge Charger_Magnum 5.7 SRT 8 Water Tank_Power Steering Cover Polished 2005-2010
12
This new cover has been designed to cover the factory water tank as well as the power
steering reservoir and will provide a nice custom look to the area. The cover is simple to
install with just a few steps.
Your new cover comes to you with a protective liner. Do not remove this liner until
prompted by instructions.
1. Remove the water tank pressure cap as well as the power steering cap. Remove the
factory bolt just above and to the right side of the tank. NOTE: This factory bolt will not
be reused.
2. Place the new cover over the tank and align the bolt hole with the one on the cover
and fasten using the pan head screw provided. Be carefully not to OVER tighten the
screw as this will distort the new cover. Just snug will be sufficient.
3. Replace the power steering cap. You have been provided with a replacement pressure
cap. To install this cap set it in place and with the palm of your hand push down firmly
and twist it on making sure it is fully rotated. Remove protective liner.
4. You have been provided with a chrome decorative cap cover, with the two tank caps
in place simply clean the factory cap with household alcohol and then swipe once with
the adhesive promoter provided then install the chrome cap by using the Velcro
attachment cookies that are attached to the under side of the new chrome cap. You
have been provided with a small chrome decorative cover for the pan head screw. This
small cap has a butyl attachment putty attached to the under side of the cap. This putty
is very reliable and need only to be pressed onto the screw head with firm pressure.
NOTE: Care must be taken when cleaning your cover. It is a good idea to lightly
dust your cover with a clean California Duster first in order to prevent any particles
from scratching them. Then wipe (using a new clean soft cloth or better yet Bounty
paper towels) with a good quality streak free glass cleaner. PLEASE SEE ENLOSED
CARE SHEET.
If any questions occur during installation, please contact American Car Craft at
727-861-1500.
Thank you for your purchase!