Owner's Manual

ManualsBrandsAmerican International ManualsAudio accessories & installationFMK-542 Dash Kit

Table Of Contents

Installation Instructions

FMK542 Mounting Kit

TECH Ver. 03/16 PRINT Ver. 09/16

VEHICLE APPLICATIONS

Ford

2009-16 ECONOLINE VAN

2007-10 EDGE

**2008-12 ESCAPE

2007-14 EXPEDITION

2006-10 EXPLORER

2007-10 EXPLORER SPORT TRAC

2004-08 F-150

*2009-12 F-150

*2013-14 F-150

(with classic dash)

2005-07 500

2005-07 FOCUS

2004-07 FREESTAR

2005-07 FREESTYLE

2006-09 FUSION

2005-09 MUSTANG

2008-09 TAURUS/TAURUS X

2005-12 SUPER DUTY

2013-16 SUPER DUTY

(with classic dash)

2012-13 TRANSIT CONNECT

Lincoln

2005-08 MARK LT P/U

2007-10 MKX (NAV only)

2007-14 NAVIGATOR (NAV only)

Mazda

**2008-11 TRIBUTE

Mercury

**2008-11 MARINER

2006-09 MILAN

2005-07 MONTEGO

2004-07 MONTEREY

2006-10 MOUNTAINEER

2008-09 SABLE

* Excludes acclimated radio/climate control panel equipped vehicles.

** This kit is compatible for vehicles equipped with the factory Navigation radio only.

Summary of content (8 pages)

PAGE 1
Ford 2009-16 2007-10 **2008-12 2007-14 2006-10 2007-10 2004-08 *2009-12 *2013-14 2005-07 2005-07 2004-07 2005-07 2006-09 2005-09 2008-09 * ECONOLINE VAN EDGE ESCAPE EXPEDITION EXPLORER EXPLORER SPORT TRAC F-150 F-150 F-150 (with classic dash) 500 FOCUS FREESTAR FREESTYLE FUSION MUSTANG TAURUS/TAURUS X 2005-12 2013-16 SUPER DUTY SUPER DUTY (with classic dash) 2012-13 TRANSIT CONNECT Lincoln 2005-08 MARK LT P/U 2007-10 MKX (NAV only) 2007-14 NAVIGATOR (NAV only) Mazda **2008-11 TRIBUTE Mercury **2008-11 M
PAGE 2
DOUBLE DIN MOUNT INSTALLATION INSTRUCTIONS NOTE: Remove support tab shown in Fig. A. 1. Attach left and right mounting brackets to the kit as shown in the figure below. 2. Insert ISO mountable radio between ISO mount brackets and loosely attach to sides of radio using screws provided with radio when possible or screws supplied with kit. 3. Slide radio forward or backward for desired look and tighten screws. 4. Support the rear of the radio component with back strap. Fig.
PAGE 3
BRACKET PREPARATION For all vehicles listed below, remove the shaded mounting tabs on both left and right brackets. Fig. A Fig. B FOR FIGURE A REMOVE SHADED MOUNTING TABS ON BOTH LEFT AND RIGHT BRACKETS FOR: FORD 500 2004-08 FORD F-150 FORD FREESTYLE FORD MUSTANG FORD TRANSIT CONNECT TAURUS/TAURUS X MERCURY MONTEGO LINCOLN MARK LT Fig. C FOR FIGURE B REMOVE SHADED MOUNTING TABS ON BOTH LEFT AND RIGHT BRACKETS FOR: FORD FREESTAR FORD FOCUS 2005-08 FORD SUPER DUTY MERCURY MONTEREY Fig.
PAGE 4
2005-07 FORD FREESTYLE DASH DISASSEMBLY INSTRUCTIONS NOTE: See illustration A on page 2 for bracket preparation 1. Open the storage compartment located above the Radio/Vent trim bezel. 2. Starting from the top edge and working your way down the sides toward the bottom, carefully pry the Radio/Climate control trim bezel forward, disconnect all harnesses from the rear of the trim bezel and remove bezel. 3. Remove the (4) 9/32 screws securing the radio to the sub-dash.
PAGE 5
2004-07 FORD FREESTAR 2004-07 MERCURY MONTEREY DASH DISASSEMBLY INSTRUCTIONS NOTE: See illustration B on page 2 for bracket preparation 1. Carefully unclip and remove the radio/climate control trim bezel from around the factory radio. 2. Disconnect the harnesses from the rear of the radio/climate control bezel and remove bezel. 3. Remove the (4) 9/32 screws securing the factory radio to the sub-dash. 4.
PAGE 6
. Remove the shift lock cover and press the shift lock button down using a small screwdriver or pen and depress the brake pedal and move the shift lever all the way to the rear. 7. Carefully pull the entire Radio/Climate control assembly forward (you will need a second person for the next step). Be careful not to scratch the sides of the dash, or the shift lever. 8. Remove the (1) 5/16 bolt securing the Ground strap to the right side of the assembly.
PAGE 7
2005-07 FORD 500 2005-07 MERCURY MONTEGO 2008-09 TAURUS/TAURUS X DASH DISASSEMBLY INSTRUCTIONS NOTE: See illustration A on page 2 for bracket preparation 1. Carefully Pry radio dash trim bezel outward, disconnect all harnesses from back of trim bezel and remove bezel. 2. Remove the (4) 9/32 screws securing the factory radio to the sub-dash. 3. Pull radio forward, disconnect all harnesses and antenna lead and remove radio.
PAGE 8
www.aampglobal.com www.aius.net 2500 East Francis Street Ontario, CA 91761, U.S.A.