Operator`s manual

AMERICAN-LINCOLN 1-15
7760
OPERATIONS OF CONTROLS AND GAUGES
IGNITION
LIGHTS
HORN
SIDE
BROO
M
LIFT
GLOW PLUG
SWITCH
CHECK ENGINE
WARNING LIGHT
(KYSOR SHUTDOWN
SYSTEM OPTION)
(DIESEL ONLY)
CHECK
ENGINE
OFF
ACC
IGN/ON
START
LIGHTS
HORN
GLOW PLUG
P-4853 FIGURE 3
GLOW PLUG SWITCH (Diesel)
Under no circumstances should any other unauthorized starting aids be used at the same time as Glow Plugs.
The Glow Plug Switch is located to the right of the steering column on the front face of the instrument console.
Use the following procedure to operate.
1. Before operating the starter motor, press the “GLOW PLUG” button for 20 to 30 seconds.
2. With the “GLOW PLUG” button still depressed, engage the starter motor until the engine starts.
3. Continue to press the “GLOW PLUG” button for a few seconds after the engine has started until even
running has been obtained.
4. If the engine does not start, disengage the starter motor, but keep the “GLOW PLUG” button depressed
for an additional 10 to 15 seconds. Keep the Glow Plugs energized while starting the engine and for a few
seconds after the engine has been running smoothly.
HORN PUSH BUTTON
The horn button is located to the right of the steering column on the front face of instrument console. The horn
button is always active. Push the horn button to sound the horn.
CHECK ENGINE (WARNING LIGHT OPTION)
This engine has a low oil pressure and low water shutdown option. If the engine oil pressure or the water level
drops too low, the engine will shut down. Add engine oil until the oil is brought up to the correct level, or water to
the radiator to the correct level.
SIDE BROOM LIFT (OPTIONAL FOR MANUAL DUMP)
The Side Broom Lift Lever is located to the right of the instrument console. The handle pulled back and turned to
the right will raise the side broom and lock it into position.