Installation Guide

STUD
SHIM
DRY WALL
TILE
SEALANT
TUB
ROOFING NAIL
51 x 102mm (2 x 4) WOOD
STRINGER FULL LENGTH
STEEL
STUD
SHIM
DRY WALL
WASHER
TILE
SEALANT
TUB
4"
DRYWALL
SCREW
A
M
E
R
I
CA
N
S
TA
N
D
A
R
D
WOOD STUDS STEEL STUDS
A
M
E
R
I
C
A
N
S
T
A
N
D
A
R
D
4
790041-400 Rev. K- 2 -
Below is shown typical cross sections of the tub rim showing typical wall constructions.
AS AMERICA, INC. LIMITED LIFETIME WARRANTY FOR
AMERICAST® PRODUCTS
If an AS America, Inc. (“American Standard”) Americast® brand
product is found to be defective in materials or workmanship,
after inspection by an authorized American Standard
representative, American Standard will repair or, at its option,
exchange the product for a similar model. This limited warranty is
applicable, so long as it remains in use in its original place of
installation, except that the limited warranty applies to a bathing
vessel’s textured bottom surface only for the first year after the
product’s initial installation.
This limited warranty applies only to the original purchaser and
installation of these products. In the event of a limited warranty
claim, proof of purchase will be required—save sales receipt.
This limited warranty does not apply to whirlpool components or
to faucets, drains, mounting rims, grab bars or other accessories.
If manufactured or supplied by American Standard, such
whirlpool components and accessories are covered under
separate limited warranties.
This limited warranty does not apply to commercial installations.
The warranty for commercial installations is three (3) years.
This limited warranty does not apply to local building code
compliance. Since local building codes vary considerably, the
purchaser of this product should check with a local building or
plumbing contractor to assure local code compliance before
installation.
This limited warranty is void if the Americast® brand product has
been moved from its initial place of installation; if it has been
subjected to faulty maintenance, abuse, misuse, accident or other
damage; if it was not installed in accordance with American
Standard’s instructions; or if it was modified in a manner
inconsistent with the product as shipped by American Standard.
American Standard's option to repair or exchange the product
under this limited warranty does not cover any labor or other
costs of removal or installation. IN NO EVENT WILL AMERICAN
STANDARD BE LIABLE FOR THE COST OF REPAIR OR
REPLACEMENT OF ANY INSTALLATION MATERIALS,
INCLUDING BUT NOT LIMITED TO, TILES, MARBLE ETC.
American Standard will not be responsible for any other incidental
or consequential damages attributable to a product defect or to
the repair or exchange of a defective product, all of which are
expressly excluded from this limited warranty. This limited
warranty does not cover any liability for consequential or
incidental damages, all of which are hereby expressly disclaimed,
or the extension beyond the duration of this limited warranty of
any implied limited warranties, including those of merchantability
or fitness for an intended purpose. (Some states or provinces do
not allow the exclusion or limitation of implied limited warranties,
so this exclusion may not apply to you.)
This limited warranty gives you specific legal rights. You may
have other statutory rights that vary from state to state or from
province to province, in which case this limited warranty does not
affect such statutory rights.
For service under these warranties, it is suggested that a claim
be made through the contractor or dealer from or through whom
the product was purchased, or that a service request (including a
description of the product model and of the defect) be sent to the
following address:
In the United States:
American Standard Brands,
P.O. Box 6820
Piscataway, New Jersey 08855
Attention: Director of Consumer Affairs
For residents of the United States, warranty
information may also be obtained by calling
the following toll free number: [phone]
www.americanstandard-us.com
In Canada:
AS Canada ULC
2480 Stanfield Rd.,
Mississauga, Ontario
Canada L4Y 1S2
Toll Free: [phone]
www.americanstandard.ca
In Mexico:
Customer Service Manager
AS Maquila, S.A. de C.V.
Via Morelos #330
Col. Santa Clara
Ecatepec 55540 Edo. Mexico
www.americanstandard.com.mx
*
PLUMBER NOTE: PROVIDE FULL LENGTH SUPPORT STRINGER AT THIS POINT
BELOW FLOOR ROUGH
2394.202 2395.202
ABOVE FLOOR ROUGH
2396.202 2397.202
LEFT HAND TUB ILLUSTRATED
RIGHT HAND TUB IS REVERSED
ROUGH FLOOR
*
FINISHED WALL
864mm
34"
1524mm
60"
19mm
3/4"
464mm
18-1/4"
ROUGH FLOOR
149mm
5-7/8"
197mm
7-3/4"
445mm
17-1/2"
349mm
13-3/4"
435mm
17-1/8"
346mm
13-5/8"
*
356mm
14"
64mm
2-1/2"
DIA.
23mm
15/16"
64mm
2-1/2"
64mm
2-1/2"
DIA.
23mm
15/16"
64mm
2-1/2"
FULL LENGTH
SUPPORT STRINGER
STD. 1-1/2
DRAIN OUTLET
19mm
3/4"
60mm
2-3/8"
PROVIDE
FULL LENGTH
SUPPORT
STRINGER AT
THIS POINT
FINISHED WALL
PROVIDE
FULL LENGTH
SUPPORT
STRINGER AT
THIS POINT
229 x 305mm
9" X 12" HOLE
IN SUB FLOOR
FOR BELOW
FLOOR ROUGH
FINISHED
WALL
FINISHED
WALL
89mm
3-1/2"