Replacement Part List

!
WARNING: Use of in
tank cleaning products
voids warranty as they
may damage parts and
cause leakage that may
lead to property damage.
FOR FURTHER ASSISTANCE
PLEASE CALL:
In the USA [phone]
www.americanstandard-us.com
In Canada [phone]
www.americanstandard.ca
REPAIR PARTS LIST
PART NO.
DESCRIPTION
Does not
flush
Poor or
sluggish
flush
Toilet leaks
Toilet does
not shut off
a. Water supply valve closed.
b. Supply line blocked.
c. Flush valve chain too loose or disconnected.
d. Sand or debris lodged in water control.
a. Bowl water level too low.
b. Supply valve partly closed.
c. Partially clogged trapway and/or drain pipe and/or vent.
d. Supply pressure too low.
a. Poor supply line connection.
b. Poor bowl to tank/floor connection.
a. Flush valve chain too tight, holding flush valve open.
b. Flush valve seat and/or flapper worn or deformed.
c. Sand or debris lodged in water control.
a. Open valve and allow water to fill tank.
b. Shut off water supply, disconnect supply line and inspect all gaskets and washers.
Reassemble. Also, see Fluidmaster maintenance.
c. Readjust chain length as required.
d. Shut off water supply. Remove cap and clean.
a. Check that refill tube is connected to water control and inserted into tank overflow without
being kinked or damaged.
b. Open supply valve fully. Be sure that proper supply tube size is used.
c. Remove obstruction. Consult a plumber if necessary.
d. Normal supply pressure must be at least 20 psi.
a. Review Step 9 of installation procedure.
b. Review Step 4 through 7 of installation procedure.
a. Readjust chain length as needed. Review Step 10.
b. Shut off water supply. Replace flush valve.
c. Shut off water supply. Remove cap and clean per Step 13.
TROUBLESHOOTING GUIDE
PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION
Please refer to
the Installation
Instructions
for detailed
corrective actions.
}
Repair parts are determined by toilet tank number which can be found marked inside tank.
NOTE: "XXX" represents color or trim finish options. Specify when ordering.
7301153-100 Rev. D
735129-400.XXX
738565-431.0070A
738565-432.0070A
738570-1030A
7381009-0070A
7381007-4000A
7381007-4010A
730512-0070A
7381008-4000A
7381004-XXX0A
738171-300.0070A
034783-XXX0A
735132-400.XXX
738565-430.0070A
738570-1000A
TANK COVER
FLUIDMASTER 400A VALVE
FLUIDMASTER 400A VALVE
FLUIDMASTER REFILL TUBE
FLUIDMASTER REFILL CLIP
FLUIDMASTER FLUSHVALVE
FLUIDMASTER FLUSHVALVE
TANK COUPLING KIT #232
FLUIDMASTER FLAPPER ASSEMBLY
TRIP LEVER ASSEMBLY LH
TRIP LEVER ASSEMBLY RH
BOLT CAP KIT #128
TANK COVER
FLUIDMASTER 400A VALVE
FLUIDMASTER REFILL TUBE
4003.016 4003.500 4003.800 4006.016 4006.800
TANK NUMBER
TANK
LEVER
"S"
CLIP
FLUSH
VALVE
TOP
ARM
NIPPLE
PARTS FOR WATER
CONNECTION
CONE WASHER
VALVE
BODY
FLAPPER
THREADED
SHANK
SHANK
WASHER
COUPLING NUT
(HAND TIGHT ONLY)
FILL
VALVE
FLOAT
CUP
CRITICAL LEVEL
MARK ("C.L.")
MUST BE
1" ABOVE
OVERFLOW PIPE
REFILL
TUBE
ADJUSTABLE
HEIGHT
WATER LEVEL
ADJUSTMENT
ROD
LOCK NUT