Installation Guide

730913-100 Rev. D
- 4 -
14
IMPORTANT: Always clear
sand and rust from system.
Make sure water supply is off.
Remove valve TOP by lifting arm
and rotating top and arm 1/8 turn
counterclockwise, pressing down
slightly on cap.
LIFT ARM
FIRST
LIFT ARM
FIRST
While holding a container over
the uncapped VALVE to
prevent splashing, turn water
supply on and off a few times.
Leave water supply off.
Replace TOP by engaging lugs
and rotating 1/8 turn clockwise.
MAKE CERTAIN TIP IS
TURNED TO THE LOCKED
POSITION. VALVE MAY NOT
TURN ON IF TOP IS NOT
FULLY TURNED TO THE
LOCKED POSITION.
For troubleshooting information please contact:
Manufacturer's First Year Fill Valve Warranty:
TROUBLESHOOTING FILL VALVE
IF FILL VALVE SHUTS OFF BUT CONTINUES TO LEAK SLOWLY, repeat Step 14.
IF FILL VALVE TURNS OFF AND ON DURING PERIODS OF NON-USE, it is a signal you are wasting water because:
• The end of the refill tube is inserted into overflow pipe, below water level in tank. Attach refill tube to overflow pipe using "S" clip provided.
• The flush valve is leaking because it's worn, dirty or misaligned (replace seal or flush valve).
IF FILL VALVE WON'T TURN ON OR SHUT OFF or REFILL OF TANK WATER IS SLOW after valve has been in use for some time, Fluidmaster
Model 242 Replacement Seal may be needed.
© 2001 Fluidmaster, Inc.
® Registered trademark of Fluidmaster, Inc.
GUARANTEE: This Fluidmaster product is guaranteed to be free from defective materials and workmanship for a period of one year. Units returned to
Fluidmaster will be replaced without charge.
Always use quality Fluidmaster repair parts when maintaining your Fluidmaster products. Fluidmaster shall not be responsible or liable for any damages
caused by products used with Fluidmaster valves that were not manufactured by Fluidmaster, Inc. See next page for American Standard Ten-Year
"Worry-Free Decade" Warranty.
30800 Rancho Viejo Road
San Juan Capistrano, CA 92675
[phone] [phone]
www.fluidmaster.com
REPAIR PARTS LIST
NOTE: "XXX" represents color or trim finish options. Specify when ordering.
Repair parts are determined by toilet tank number which can be found marked inside tank.
PART NO. DESCRIPTION
738837-XXX0A
034783-XXX0A
738565-409-0070A
738651-0070A
3175.002-0070A
738930-0070A
738657-0070A
738756-0070A
735113-400-XXX
072989-0070A
WILLIAMSBURG CHAMPION® TRIP LEVER
BOLT CAP KIT (INCL TWO COVERS & WASHERS)
CHAMPION® FLUIDMASTER 400A VALVE
CHAMPION® FLUSH VALVE SEAL
CHAMPION® FLUSH VALVE ASSEMBLY
CHAMPION® BEAD CHAIN WITH CLEVIS PIN
CHAMPION® SILICON REFILL TUBE
CHAMPION® TANK TO COUPLING KIT #241
WILLIAMSBURG CHAMPION® TANK COVER
CLIP FOR REFILL TUBE