INSTALLATION GUIDE FOR LIFETIME™ / EVOLUTION™ WHIRLPOOLS AND BATHTUBS MODEL 2422L / LA / V / VA 5' x 32" MODEL 6060L / V CORNER MODEL 2771L / LA / V / VA 5' x 36" MODEL 2645L / LA / V / VA OVAL MODEL 7236L / LA / V / VA 6' x 36" MODEL 2425L / V - LHO 5' x 32" IA-LHO MODEL 2425L / V - RHO 5' x 32" IA-RHO MODEL 2901L SAVONA MODEL 2908L / LA REMINISCENCE MODEL 2711L ELLISSE MODEL 2773L CADET 6' x 36" MODEL 2774L / LA CADET 6' x 42" MODEL 2775L CADET CORNER MODEL 2805L 5' x 42" THAN
TABLE OF CONTENTS: Safety Instructions............................................................................Page 3 General Information..........................................................................Page Optional Components.......................................................................Page Specifications....................................................................................Page 5 Roughing-in Reference...............................................................
IMPORTANT SAFETY INSTRUCTIONS INSTRUCTIONS PERTAINING TO A RISK OF FIRE, ELECTRIC SHOCK OR INJURY TO PERSONS READ AND FOLLOW ALL INSTRUCTIONS! ! WARNING: Risk of personal injury. Do not permit children to use this unit without adult supervision. ! WARNING: Risk of personal injury. Do not operate this unit without the guard over the suction fitting. ! WARNING: Risk of electric shock. Do not permit electrical appliances (hair dryer, telephone, radio, etc.) within 0 inches (15 mm) of this unit.
General Installation Information Carefully uncrate and inspect your new bath for any shipping damage. If such damage is found, report it to your vendor immediately. After inspection and during installation, protect the bath from construction damage. Before installation, and before enclosing with wallboard, tile, etc.
SPECIFICATIONS: L W J H SIDE VIEW C A END VIEW B DRAIN / OVERFLOW GENERAL SPECIFICATIONS FOR LIFETIME / EVOLUTION WHIRLPOOLS AND BATH TUBS Description 0 0L / V Corner* Dimensions L-W-H Drain / Overflow L 1 mm (7 -3/ ") A 1 " W 1 1mm ( 5-3/ ") ( 57 mm) H 5 mm ( 1-1/ ") B 13-3/ " (3 mm) L / LA / V / VA 5' x 3 " L 15 mm ( 0") W 13mm (3 ") H 5 mm ( 1-1/ ") A 0-1/ " (511 mm) B 11" ( 7 mm) 771L / LA / V / VA 5' x 3 " L 15 mm ( 0") W 1 mm (3 ") H 5 mm ( 1-1/ ") A 0-1/ " (51
ROUGHING-IN REFERENCES 6' x 36" (MODEL 7236L / LA / V / VA) 5' x 32" (MODEL 2422L / LA / V / VA) 7 " (1 mm) 0" (15 mm) 13-3/ " (3 mm) 3" (7 mm) 3 " ( 13mm) " (15 mm) CUT OUT IN FLOOR FOR DRAIN 3" (7 mm) 3-1/ " ( 3mm) 13-3/ " (3 mm) 7-3/ " (1 7mm) 3 " ( 1 mm) " (15 mm) 7-3/ " (1 7mm) CUT OUT IN FLOOR FOR DRAIN 11" ( 7 mm) 3-1/ " ( 3mm) 5' x 36" (MODEL 2771L / LA / V / VA) 0" (15 mm) 11" ( 7 mm) OVAL (MODEL 2645L / LA / V / VA) 11" ( 7 mm) " (1 7 mm) 11-1/ " ( mm) 3-1/ " (
ROUGHING-IN REFERENCES CORNER (MODEL 6060L / V) SAVONA (MODEL 2901L) 76-3/4" (1949mm) 72" (1829mm) 54-1/2" (1384mm) 65-3/8" (1661mm) 44" (1118mm) 11-1/2" (292mm) 15" (381mm) 5-5/8" (143mm) 17-3/4" 7" (451mm) (178mm) 7" (178mm) 3" (76mm) 6" (152mm) 8" (203mm) 3" (76mm) 10" (254mm) 12" (305mm) 5-1/2" (140mm) 13-3/4" (349mm) CUT OUT IN FLOOR FOR DRAIN ● RECOMMENDED FITTING LOCATION 64 X 279mm (2-1/2 X 11) CADET CORNER (MODEL 2775L) m m 2 4 0 ") 5 6 1 ( 1080mm (42-1/2") 229 X 305mm (9" X 1
ROUGHING-IN REFERENCES REMINISCENCE (MODEL 2908L / LA) CADET 6 x 42 (MODEL 2774L / LA) 1 7 mm ( ") 330mm (13") PROVIDE ACCESS TO PUMP FOR SERVICING ON ALL INSTALLATIONS PUMP 1 mm (3 ") 57mm (1 ) INTEGRAL FITTING DECK mm ( ) x 305mm ( X 1 ) FLOOR CUTOUT FINISHED WALL mm REF.
INSTALLATION AND FRAMING INSTRUCTIONS The variety of installations possible for this whirlpool may require framing procedures other than those shown. Locate studs as needed. Ensure roughing-in dimensions are proper, plumb and square. Provisions must be made in all installations for an access opening for servicing the pump and controls. It is strongly recommended that an additional opening be provided for access to the drain components. The apron should not be used as the primary access opening. 1.
TYPICAL FLANGE MOUNTING DETAIL SUGGESTED WHIRLPOOL / BATH INSTALLATION METHOD WOOD STUDS TYPICAL INSTALLATION CORNER STUD WATERPROOF DRYWALL OR CEMENT BOARD TILE ROOFING NAIL SEALANT TUB 1 -1/ ( 5mm) 1 x 3 ( 5 x 7 mm) WOOD STRINGER FULL LENGTH STEEL STUDS STEEL STUD WATERPROOF DRYWALL OR CEMENT BOARD WHIRLPOOL ACCESS PANEL WASHER TILE SEALANT TUB * SEE CUTOUT TEMPLATE PROVIDED ON UNDERSIDE OF BOX LID " (10 mm) DRYWALL SCREW 1 x 3 ( 5 x 7 mm) WOOD STRINGER FULL LENGTH UNLESS AN ACCESS OPE
WHIRLPOOL ELECTRICAL INSTALLATION INSTRUCTIONS All wiring must be performed by a licensed electrician in accordance with the national electrical code and all other applicable codes. ! WARNING: When using electrical products, basic precautions should always be observed, including the following: 1. DANGER: RISK OF ELECTRIC SHOCK! Connect only to a circuit protected by a ground-fault circuit interrupter. . Grounding is required. The unit should be installed by a licensed electrician and grounded. 3.
For 6060L/V Corner Only OPERATION Fig. 1 WARNING: Prior to operation, review the Important Safety Instructions listed at the beginning of this instruction manual. Once the heater is installed and the whirlpool pump is operating, the heater is totally automatic. The heater will help maintain the temperature of the water in the bath. E-Z INSTALL™ HEATER WHIRLPOOL HEATER “ON” LIGHT Pressure Switch FACTORY INSTALLED - NOT FOR RESALE The heater is equipped with a preset pressure switch.
DRAIN CONNECTION AND SYSTEM TEST Using recommended drain assembly, connect whirlpool drain to waste line in accordance with the drain assembly instructions. Tighten all drain joints securely. Check the pump couplings and make sure they are hand-tight. Clean the whirlpool and fill with water to a point " above the top of the highest jet. Recheck the pump couplings and make certain that they are not leaking.
AS AMERICA, INC. (AMERICAN STANDARD) LIMITED LIFETIME WARRANTY FOR LIFETIME™ / EVOLUTION™ ACRYLIC WHIRLPOOLS AS America (“American Standard”) warrants to the original consumer purchaser that it will, at its option, repair or replace this whirlpool or any of its parts that are found by American Standard, in its sole judgment, to be defective under normal residential use and maintenance so long as it is owned by the original consumer purchaser.
-JGFUJNF &WPMVUJPO 8IJSMQPPM BOE #BUIT 0QFSBUJOH BOE 6TFS .BJOUFOBODF *OTUSVDUJPO .
*.
0QFSBUJPO /05& &BDI XIJSMQPPM JT TIJQQFE GSPN UIF GBDUPSZ XJUI BO BJS BDUVBUPS PO PGG TXJUDI BOE QVNQ XJUI BUUBDIFE QPXFS TVQQMZ DPSE 01&3"5*/( 5)& 4:45&. 8*5)065 8"5&3 %3: 36//*/( 8*-- $"64& 16.1 %".
"EKVTUBCMF 'MPX $PNGPSU +FU 5IF XBUFS GMPX BDUJPO NBZ CF BEKVTUFE GSPN WJHPSPVT UP TPGU CZ SPUBUJOH UIF OP[[MF DPVOUFSDMPDLXJTF GPS WJHPSPVT BOE DMPDLXJTF GPS TPGU /05& :PV NBZ CBMBODF UIF BJS WPMVNF DPOUSPM BOE OP[[MF BEKVTUNFOU GPS UIF NPTU EFTJSBCMF DPOEJUJPO -BSHF +FU 4NBMM +FU 4PGUFS .BTTBHF DPVOUFS DMPDLXJTF 4PGUFS .BTTBHF DPVOUFS DMPDLXJTF .PSF 7JHPSPVT .BTTBHF DMPDLXJTF .PSF 7JHPSPVT .BTTBHF DMPDLXJTF -JGFUJNF %SBJO .PEFM SFRVJSFE PO .
0QUJPOBM *O -JOF &; *OTUBMM )FBUFS 0QFSBUJOH *OTUSVDUJPOT 4PNF XIJSMQPPMT BSF FRVJQQFE GPS VTF XJUI UIF PQUJPOBM &; *OTUBMM )FBUFS 8IJSMQPPM #BUI )FBUFS QBSU OP 4JNQMZ MPDBUF UIF &; *OTUBMM )FBUFS 3FNPWBCMF #MBOL OFBS UIF XIJSMQPPM QVNQ BOE SFQMBDF JU XJUI UIF IFBUFS #F TVSF UP '0--08 "-- 01&3"5*/( */45"--"5*0/ BOE 4"'&5: */4536$5*0/4 5)"5 $0.
ELECTRICAL CONNECTIONS Install a separate 120VAC / 15AMP dedicated circuit with GFCI (Ground Fault Circuit Interrupter) protection. At initial start-up with power ON, push the GFCI test button. The reset button should pop out. Push this button in to reset. If the GFCI fails to operate in this manner, there is a ground fault or malfunction, indicating the possibility of electrical shock. Turn off the power and do not use the bath until the source of the problem has been identified and corrected. 1.
)"34) $)&.