Installation Guide

7301450-100 Rev. A
Does not flush
Poor or sluggish flush
Toilet leaks
Toilet does not shut off
a. Water supply valve closed.
b. Supply line blocked.
c. Flush valve chain too loose or disconnected.
d. Sand or debris lodged in water control.
a. Bowl water level too low.
b. Supply valve partly closed.
c. Partially clogged trapway and/or drain pipe and/or vent.
d. Supply pressure too low.
e. Flush valve chain too tight, holding flush valve open.
a. Poor supply line connection.
b. Poor bowl to tank/floor connection.
a. Flush valve seal leaking or deformed.
b. Sand or debris lodged in water control.
a. Open valve and allow water to fill tank.
b. Shut off water supply, disconnect supply line and inspect all
gaskets and washers. Reassemble. Also, see Fluidmaster
maintenance. (see Step 12)
c. Readjust chain length as required.
d. Shut off water supply. Remove cap and clean as per Step 12.
a. Check that refill tube is connected to water control and
inserted into tank overflow without being kinked or damaged.
b. Open supply valve fully. Be sure that proper supply tube size
is used.
c. Remove obstruction. Consult a plumber if necessary.
d. Normal supply pressure must be at least 20 psi.
e. Readjust chain length as needed. Review Step 9A.
a. Review Step 8a and 8b of installation procedure.
b. Review Step 4 through 6 of installation procedure.
a. Clean debris from seal surface. Replace flush valve seal as
needed.
b. Shut off water supply. Remove cap and clean as per Step 12.
TROUBLESHOOTING GUIDE
PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION
- 4 -
REPAIR PARTS LIST
NOTE: "XXX" represents color options. Specify when ordering.
DESCRIPTION
BOULEVARD TROPIC TOWN SQUARE
COMPONENT
1.6
GPF
1.28
GPF
Tank Cover, Boulevard
Tank Cover, Tropic
Tank Cover, Town Square
Slow Close Contemporary EL Seat
Slow Close Transitional EL Seat
Slow Close Traditional EL Seat
Bolt Cap Kit
Bolt Cap Kit
Trip Lever, Boulevard
Trip Lever, Tropic
Trip Lever, Town Square
Inlet Valve - 1.6 GPF
Flush Valve - 1.6 GPF
Flapper Assembly - 1.6 GPF
Inlet Valve - 1.28 GPF
Flush Valve - 1.28 GPF
Flapper Assembly - 1.28 GPF
735148.XXX0A
735147.XXX0A
735150.XXX0A
5218.110.XXX
5216.110.XXX
5214.110.XXX
7381073-XXX0A
730835-XXX0A
7381064-XXX0A
7381097-XXX0A
7381105-XXX0A
738565-439.0070A
738942-100.0070A
738920-100.0070A
738565-438.0070A
738942-102.0070A
7381043-400.0070A
√
√
√
√
√
√
√
√
√
√
√
√
√
√
1.6
GPF
1.28
GPF
√
√
√
√
√
√
√
√
√
√
√
√
√
√
1.6
GPF
1.28
GPF
√
√
√
√
√
√
√
√
√
√
√
√
√
√