Instructions / Assembly

ManualsBrandsAmericana ManualsOutdoorsTraveler Charcoal Grill in black

For Outdoor Household Use Only. Not for Commercial Use.

Need Help? Need to Register Your Grill? Looking for Parts & Accessories?

Visit us online at www.onefiregrills.com Or call Customer Service at 1-800-251-7558

• This instruction manual contains important information necessary for the proper

assembly and safe use of this appliance. Failure to follow these instructions could

result in death or serious injury from explosion or fire.

• Read and follow all warnings and instructions carefully before assembling or using

this appliance.

• Keep this manual for future reference. SAVE THESE INSTRUCTIONS.

WARNING

Charcoal Grill User’s Manual

The Traveler

100% Portable Charcoal Grill

Just Fold up and Go!

Simply makes your grill portable and

compact for storage.

Model 3400

P/N 03.1558.00 Rev. 20121204

Summary of content (8 pages)

PAGE 1
The Traveler 100% Portable Charcoal Grill Just Fold up and Go! Simply makes your grill portable and compact for storage. Model 3400 Charcoal Grill User’s Manual For Outdoor Household Use Only. Not for Commercial Use. ! WARNING • This instruction manual contains important information necessary for the proper assembly and safe use of this appliance. Failure to follow these instructions could result in death or serious injury from explosion or fire.
PAGE 2
DANGE R ! CARBON MONOXIDE HAZARD This appliance can produce carbon monoxide, an odorless toxic gas. Using it in an enclosed space can kill you. Never use this appliance in an enclosed space, such as a camper, tent, car, or home. This appliance is not intended for and should never be used as a heater. Meco Corporation strives to be a quality supplier of consumer products.
PAGE 3
Preparation for Assembly TOOLS NEEDED: Straight and Phillips head Screwdrivers and a 3/8” open end wrench or a pair of pliers. Pull the Cooking Grid straight up until it snaps out of the Bowl and lay it aside. Note that the Cooking Grid fits tight to remain in place when you transport your Traveler grill. Remove all the other parts. DO NOT DISCARD CARTON OR PACKING UNTIL YOUR GRILL IS COMPLETELY ASSEMBLED. LAY OUT AND IDENTIFY ALL PARTS.
PAGE 4
Step 2 LEG ASSEMBLY TO BOWL Place the Bowl on its side on the floor or on a flat work surface. Orient the Leg Assembly as shown with the loose leaf of the hinges facing the center of the Bowl. Align the outer hole in each hinge with the corresponding holes in the Bowl and put a 10 -24 x 1/2” Screw through the outer hole in the hinge then the hole in the Bowl. Fasten in place with Washer Locknuts. Hold the Washer Locknut and turn the Screw.
PAGE 5
Step 5 HINGE ASSEMBLY Align holes in the Left Hand Hinge Assembly with the two matching holes on the left inside of the Bowl. The short hinge with the bend should be nearest the rear of the bowl. Put a 10-24 x 1/2” Screw through the mounting bracket part of the Hinge Assembly and the Bowl. Attach an Acorn Locknut to the Screw from the outside of the Bowl. Repeat for the other mounting hole and tighten both screws. Repeat this step for the Right Hand Hinge Assembly.
PAGE 6
USING CHARCOAL To reduce the risk of serious injury or death from explosion or fire: • Be careful when burning charcoal to avoid getting burned from flame, heat or hot coals. • Be aware of the wind blown sparks. • The use of alcohol, prescription or non-prescription drugs could impair the consumer’s ability to properly assemble or safely operate this appliance.
PAGE 7
STARTING A CHARCOAL FIRE IN YOUR ONE FIRE TRAVELER GRILL STEP 1. Use a high quality hardwood charcoal to make sure you get a good fire. Charcoal briquettes made from maple, oak, birch or elm woods will burn clean with very little smoke and without unpleasant odors. STEP 2. Open the hood and all the vents. STEP 3. Remove the Cooking Grid. Line the bottom of the Bowl with heavy duty aluminum foil. STEP 4. Place about three pounds of charcoal (35-40 briquettes) in the bottom of the grill. STEP 5.
PAGE 8