Golden Fry Installation, User Operation, & Maintenance Manual

ManualsBrandsAnetsberger Brothers ManualsFryerFM-14

Anetsberger Brothers, Inc.

180 North Anets Drive • Northbrook, Illinois 60062 • 847-272-0770 • Fax 847-272-1943

For ANETS Factory Warranty Service • 800-837-2638

Installation,

User Operation,

Maintenance

Manual

Keep this Manual in a Convenient Location for Reference

The Anets GoldenLine

Quality Equipment For The Restaurant, Supermarket, and Bakery Industries

WARNING

After installation of this equipment, immediately contact your local gas

supplier to obtain information about what action to take whenever any

person smells gas. Post this information in a prominent location.

DANGER

Improper installation, adjustment, alteration, service, or maintenance can

cause property damage, injury or death. Read the installation, operating

and maintenance instructions thoroughly before installing or servicing this

equipment.

Form I-225

Rev. 6/03

Price $20.00 US

FOR YOUR SAFETY

DO NOT store or use gasoline or other flammable vapors

or liquids in the vicinity of this or any other appliance.

GoldenFRGoldenFR

GoldenFR

Model FM-14 Filter Mate

shown under the base system

of (2) 14” fryers

Model Filt II-14W shown banked

to (2) 14” fryers

Models

FM-14 Filter Mate

FM-18 Filter Mate

Filt II-14/14W Filtronic

Filt II-18/18W Filtronic

FM-14

FM-18

Filt II-14/14W

Filt II-18/18W

Summary of content (9 pages)

PAGE 1
Anetsberger Brothers, Inc.
PAGE 2
TABLE OF CONTENTS Shipping Container Inspection ....................................................... 2 Code Requirements ...................................................................... 2 Filter Unit Preparation Instructions ................................................ 3 Filter System Diagrams .................................................................. 4 Filtering Instructions ...................................................................... 5 Oil Disposal Instructions .............
PAGE 3
INST ALLA TION INSTALLA ALLATION This Manual will detail the Installation and Operation of the FilterMate system, with notes where the Filtronic II System differs. Both the Filter Mate and Filtronic II Systems enable the user to safely and efficiently filter the cooking oil or shortening from a fryer in a banked row while the other fryers in that row are still being used.
PAGE 4
FIL TER MA TE TANK FILTER MATE Filter envelope clip Lift out handle Quick connect coupling Knurled retaining nut Pump quick-connect coupling Filter envelope Return line and optional hose connection FIL TR ONIC II TANK FILTR TRONIC Lift out handle Quick connect coupling Pump quick-connect coupling Knurled retaining nut Filter envelope Filter envelope clip 4
PAGE 5
FIL TERING INSTR UCTIONS FILTERING INSTRUCTIONS CAUTION Never operate the filter unit unless the cooking oil or shortening in the fryers has been brought up to cooking temperature. WARNING Always wear protective heat-resistant gloves when performing the filtering operation. FIL TERING FILTERING 1. Before filtering the shortening in a fryer, turn the thermostat knob to “OFF” or the Gas Valve to “PILOT” to prevent the fryer from re-lighting during filtering.
PAGE 6
. On gas-operated thermostat models (14G, 14GS, MXEG, 18EG, 20EG) the thermostat knob can now be turned back to the desired temperature. CAUTION: On these models the thermostat must be set to “OFF” or the Gas Valve to “PILOT” before filtering or the burners MAY come back on if the doors are closed during filtering. 7. On electric-operated thermostat models (MX-14E, MX-14AA, 18E, 18AA, 20E, and 14EL-17) the power switch on the control panel must be reset for the fryer to operate again. 8.
PAGE 7
REPLA CING THE FIL TER P APER REPLACING FILTER PAPER If the filter paper becomes torn, or if the time to filter the oil from one unit becomes excessive, it is time to replace the Filter Envelope. ! DANGER ! Make sure the filter pan has cooled completely to room temperature before attempting to change the paper. 1. Disconnect the oil return line from the pump. 2. Unplug the cord from the receptacle on the side of the cabinet. 3. Pull the filter unit from the cabinet. 4.
PAGE 8
FIL TER SY STEM TR OUBLESHOO TING GUIDE FILTER SYSTEM TROUBLESHOO OUBLESHOOTING PROBLEM SOL UTION SOLUTION Pump does not start when the return line valve (yellow handle) on the fryer is opened. 1. Make sure the power cord is plugged into the receptacle in the cabinet and the main power cord from the system is plugged into the appropriate power supply. 2. Turn the switch on the side of the filter to “ON”. 3.
PAGE 9
LIMITED WARRANTY ANETSBERGER BROTHERS, INC., Northbrook, Illinois, USA, certifies that all equipment of its manufacture is, to the best of its knowledge, free from defective material and workmanship. ANETSBERGER BROTHERS, INC., agrees to replace any integral part of its equipment that proves defective within 15 months of date of original shipment from the factory, or 12 months from the date of installation, whichever is sooner.