Manufacturing Numbers: 9700465 9700475 Water filtration system System Tested and Certified by NSF International and WQA against NSF/ANSI Standard 42 and 53 for the reduction of: UFL-420/440 Series Standard No. 42: Aesthetic Effects Nominal Particulate Reduction Class I Standard No. 53: Health Effects Cyst Reduction Turbidity Reduction.
UFL-420/440 water Filtration system Table of contents Owner Information......................................................2 General.......................................................................2 Warranty Information..................................................2 Service/Technical Assistance.....................................3 Important Safety Information.....................................4 Specifications..............................................................5 Dimensions...........
UFL-420/440 water filtration system Owner information (continued) Service/Technical Assistance Suggested replacement period for Ultra Filter Cartridge is approximately 3 years. If you experience any problems with the installation or operation of your unit, contact Antunes Filtration Technologies at 1-630-784-1000, or toll free in the United States at 1-800-253-2991. For sales in the state of Iowa: Fill in the information in the next column and have it handy when calling for assistance.
UFL-420/440 water Filtration system Important Safety Information In addition to the warnings and cautions in this manual, use the following guidelines for safe operation of the unit: • If the supply cord is damaged, it must be replaced by the manufacturer or its service agent or a similarly qualified person. • Read all instructions before using equipment. • This equipment is to be installed to comply with the local plumbing code and any other applicable code.
UFL-420/440 water filtration system Specifications Dimensions Electrical Ratings UFL-420 UFL-440 B B Model & Mfg. No. Voltage Watts UFL-420 9700465 100–240 UFL-440 9700475 100–240 Amps Hertz 10 0.4 50/60 10 0.4 50/60 Electrical Cord & Plug Configurations A A C Kit Model Number Description 0012146 DC Power Supply 100 - 240 VAC Includes the 4 plug adaptors below Configuration NOTE: PLUG STYLE MAY VARY US NEMA 1-15 (2 pin) or NEMA 5-15 (3 Pin) Euro CEE 7/16 C Model & Mfg. No.
UFL-420/440 water Filtration system Specifications (continued) Permeate Outlet Drain Valve Flush Button Mounting Bracket Filter Housing Power Transformer Flow Controller Inlet Figure 1.
UFL-420/440 water filtration system Performance Data Sheet Ultra Filter Cartridge Capacities Max.Operating Pressure Max. Operating Temp. Min. Operating Temp. Max. Trans Membrane Pressure pH Range MWCO System Tested and Certified by NSF International against NSF/ANSI Standard 42 and 53 for the reduction of: 100 psig (690 kPa) 104°F (40°C) 40°F (4°C) 45 psi (3.1 bar) 3-10 100 kD Standard No. 42: Aesthetic Effects Nominal Particulate Reduction Class I Standard No.
UFL-420/440 water Filtration system Overview Overview The UFL system operates in two modes: • Normal Operation Mode • Flush Mode During Normal Operation Mode, water enters the Inlet and flows through the Ultra Filter before exiting the Permeate Outlet as usable product water. During Flush Mode, the Drain Valve opens and water entering the Inlet flushes and cleans the Ultra Filter membrane by removing any debris collecting on the membrane wall. The Drain Valve is only powered during Flush Mode.
UFL-420/440 water filtration system Installation Unpacking Plumbing 1. Remove the system and all packing materials from the shipping carton. NOTE: This unit is designed to use tap water not to exceed 100°F (38°C) or 100 psig (690 kPa). 2. Remove all packing materials and protective coverings from the system The UFL-420 and UFL-440 systems use the following connections (Figure 1): 3. Remove the information packet. To prevent any delay in obtaining warranty coverage, fill out and mail the warranty card.
UFL-420/440 water Filtration system Flow Regulator Assembly Installation (continued) Inlet Water Plumbing Your filtration system uses a water Flow Regulator Assembly that controls the flow of water into the unit. This assembly consists of a white threaded male connector and a color-coded Flow Regulator (Figure 3). The unit MUST be operated with the appropriate Flow Regulator Assembly. • UFL-420 Units: Use a GREEN and WHITE Flow Regulator Assembly (5 gallons per minute).
UFL-420/440 water filtration system Installation (continued) Permeate Line Plumbing Secure End To ensure the highest quality and safest water, it is recommended that a check valve (to prevent backflow) be installed in the water line after the permeate connection. This will help prevent possible contamination of the filter system due to other equipment downstream. The check valve (not supplied) should be mounted close to the system outlet, and sized properly for the plumbing line.
UFL-420/440 water Filtration system Installation (continued) Starting the Controller Rinsing the Ultra Filter Cartridge 1. Select the proper AC plug for your electrical outlet and install it onto the power supply. The Ultra Filter Cartridge must be rinsed before the system is used to remove any air and protective solution. 2. Plug the appropriate end of the power cord into the controller.
UFL-420/440 water filtration system Installation (continued) Sanitizing the System and Lines IMPORTANT Commonwealth of Massachusetts Plumbing Code 248 CMR shall be adhered to. The use of saddle valves are not permitted, please consult your local plumber. The plumbing must be sanitized to eliminate possible contamination that may have occurred during the installation process. One ounce (30 ml) of liquid chlorine bleach (regular bleach, unscented 6% sodium hypochlorite) can be used to sanitize the plumbing.
UFL-420/440 water Filtration system Maintenance Replacing the Ultra Filter Cartridge 1. Turn off water to the system by closing the inlet valve. 2. Press the FLUSH button to flush the system and relieve pressure. Repeat several times. 3. Place a bucket under the “T” or cross fitting at the inlet connection to the system. Open the valve or unscrew the cap to drain the system. Ultra Filter Cartridge NOTE: Make sure there is enough room next to the system to remove the cartridge. 4.
UFL-420/440 water filtration system maintenance (continued) Changing the Interval Setting Caution Changing the flush interval can cause the Ultra Filter to plug prematurely and may void the warranty. Consult the factory for more information. Though not recommended, the Interval Setting on the controller can be changed. If the setting must be changed, use the chart below. Press and hold the corresponding button. After 5 seconds, the Button LED will turn on. After 10 seconds, the Flush LED will also turn on.
UFL-420/440 water Filtration system Troubleshooting Problem Possible Cause Corrective Action Unit does not have power. The power cord is not correctly plugged in. Plug power cord in correctly. The Control Display is blank. The power cord is not correctly plugged in. Plug power cord in correctly. Control Board is inoperable. Transformer is inoperable. Contact your maintenance person or Authorized Service agency.
UFL-420/440 water filtration system Replacement Parts Replacement Parts can be purchased from an authorized dealer.
UFL-420/440 water Filtration system Replacement Parts (continued) Replacement Parts can be purchased from an authorized dealer. Contact Antunes Filtration Technologies at 1-630-754-1000 or toll free in the United States at 1-800-253-2991 Item 1 2 3 4 5 6 7 8 Part No. 2190150 2190147 2180181 2180228 7000413 0200235 0200236 2140153 0504065 3080157 7000411 7000412 Description Qty.
UFL-420/440 water filtration system Notes P/N 1011055 11/09 19
LIMITED WARRANTY Equipment manufactured by Antunes Filtration Technologies, a Division of A.J. Antunes & Co., has been constructed of the finest materials available and manufactured to highest quality standards. These units are warranted to be free from defects in material and workmanship for a period of on year from date of purchase under normal use and service, and when installed in accordance with the manufacturer’s recommendations.