Safety data sheet
Media
reaction which will result.
5.2 Special hazards arising from the substance or mixture
Unusual Fire and Explosion
Hazards
●
Hydrogen and oxygen gases are produced during normal battery operation and
charging. These gases escape through the battery vents and may form an explosive
atmosphere around the battery if ventilation is poor. Avoid open flame, sparks and
other ignition sources in areas where batteries are used or stored.
Hazardous Combustion
Products
●
Acid mists and vapors, toxic fumes from burning plastic.
5.3 Advice for firefighters
●
Fire fighters should wear complete protective clothing including self
-
contained
breathing
apparatus.
Wear chemical protective clothing that is specifically recommended by the
manufacturer. It may provide little or no thermal protection.
Fire fighters to wear acid
-
resistant full protective clothing, including rubber footwear
and self
-
contained breathing apparatus.
Section 6
-
Accidental Release Measures
6.1 Personal precautions, protective equipment and emergency procedures
Personal Precautions
●
Do not walk through spilled material. Wear appropriate personal protective equipment,
avoid direct contact. Do not touch damaged containers or spilled material unless
wearing appropriate protective clothing. Ventilate enclosed areas. Do not get in eyes,
on skin, or on clothing. Do not breathe dusts or mists.
Emergency Procedures
●
As an immediate precautionary measure, isolate spill or leak area for at least 50
meters (150 feet) in all directions. Keep unauthorized personnel away. Do not get
water inside container.
6.2 Environmental precautions
●
Avoid run off to waterways and sewers.
6.3 Methods and material for containment and cleaning up
Containment/Clean
-
up
Measures
●
Stop leak if you can do it without risk.
If battery is leaking, place battery in a heavy duty plastic bag.
Contain spill by diking with soda ash, etc.
Neutralize spill area with (soda ash or lime, dilute with acetic acid)
Make certain mixture is neutral then collect residue and place in a drum or other
suitable container.
6.4 Reference to other sections
●
Refer to Section 8
-
Exposure Controls/Personal Protection and Section 13
-
Disposal
Considerations.
Section 7
-
Handling and Storage
7.1 Precautions for safe handling
Handling
●
Use only in well ventilated areas. Use caution when combining with water; DO NOT
add water to corrosive liquid, ALWAYS add corrosive liquid to water while stirring to
prevent release of heat, steam and fumes. Wear appropriate personal protective
equipment, avoid direct contact. Do not get in eyes, on skin, or on clothing. Do not
breathe mist, vapors, spray. Avoid direct conductive connection across positive and
negative terminals to prevent short circuit. Wash thoroughly with soap and water after
handling and before eating, drinking, or using tobacco.
7.2 Conditions for safe storage, including any incompatibilities
Storage
●
Batteries should be kept in an upright position away from ignition sources. Stack
batteries so as to prevent accidental contact between terminal and/or other damage to
terminals or containers. Whenever feasible, store on shipping pallet or rack. Do not
stack loaded pallets or racks on top of other batteries. Store in a cool/low
-
temperature, well
-
ventilated place. Avoid storage in areas exposed to heat or solar
Battery pack containing sealed lead acid batteriesBattery pack containing sealed lead acid batteriesBattery pack containing sealed lead acid batteriesBattery pack containing sealed lead acid batteries
Preparation Date: 23/May/2014Preparation Date: 23/May/2014Preparation Date: 23/May/2014Preparation Date: 23/May/2014
Revision Date: 23/May/2014Revision Date: 23/May/2014Revision Date: 23/May/2014Revision Date: 23/May/2014
Format: EU CLP/REACH Language: English (US)Format: EU CLP/REACH Language: English (US)Format: EU CLP/REACH Language: English (US)Format: EU CLP/REACH Language: English (US)
WHMIS, EU CLP, EU DSD/DPD, OSHA HCS 2012WHMIS, EU CLP, EU DSD/DPD, OSHA HCS 2012WHMIS, EU CLP, EU DSD/DPD, OSHA HCS 2012WHMIS, EU CLP, EU DSD/DPD, OSHA HCS 2012
Page 6 of 21Page 6 of 21Page 6 of 21Page 6 of 21